SDS

ManualsBrandsArmacell ManualsPlumbing ProductLow VOC 520 Pipe Insulation Adhesive

Armaflex



520 BLV Contact Adhesive Page 1 of 8

12-May-2015

SAFETY DATA SHEET

Manufacturer’s name and address:

Armacell LLC

P.O. Box 839

7600 Oakwood Street Extension

Mebane, NC 27302

USA

Supplier’s name and address:

Refer to Manufacturer

Information Telephone No. : (919) 304-3846

Website Address : http://www.armacell.us

24 Hr Emergency Telephone # : CHEM-TEL: 1-800-255-3924 OR 1-813-248-0585 (call collect)

Product Identifier : Armaflex



520 BLV Adhesive

Chemical Name : N/Ap Chemical Family : Mixture

Chemical Formula` : N/Ap Trade Name/Synonyms : Armaflex 520 BLV

Molecular Weight : N/Ap Material Use : Low VOC contact adhesive.

Uses Advised Against : No information available.

HMIS Rating : * - Chronic Hazard 0 - Minimal 1 – Slight 2 – Moderate 3 – Serious 4 – Severe

Health: *2 Flammability 3 Physical Hazard 0

GHS Classification per 29 CFR 1910.1200 (OSHA HCS 2012) and HPR (WHMIS 2015)

Flammable liquids; Category 2 (Flammable)

Skin corrosion/irritation; Category 2 (Irritant)

Serious eye damage/eye irritation; Category 2A (Serious Irritant)

Sensitisation, Skin; Category 1

Specific target organ toxicity, single exposure; Narcotic effects; Category 3

Reproductive toxicity; Category 2

Aspiration hazard; Category 2

GHS Pictograms

Signal Word

Danger

Hazard Statements

Highly flammable liquid and vapor.

Causes skin irritation and serious eye irritation.

May cause an allergic skin reaction.

May cause drowsiness or dizziness.

Suspected of damaging fertility or the unborn child.

May be harmful if swallowed and enters airways.

Precautionary Statements

Obtain special instructions before use. (See Section 7.) Do not handle until all

safety precautions have been read and understood. Keep away from

heat/sparks/open flames/hot surfaces. — No smoking. Keep container tightly

SECTION 1 – IDENTIFICATION

SECTION 2 – HAZARDS IDENTIFICATION

Summary of content (8 pages)

PAGE 1
Armaflex 520 BLV Contact Adhesive 12-May-2015 Page 1 of 8 SAFETY DATA SHEET SECTION 1 – IDENTIFICATION Manufacturer’s name and address: Supplier’s name and address: Refer to Manufacturer Armacell LLC P.O. Box 839 7600 Oakwood Street Extension Mebane, NC 27302 USA Information Telephone No. Website Address 24 Hr Emergency Telephone # : (919) 304-3846 : http://www.armacell.
PAGE 2
Armaflex 520 BLV Contact Adhesive 12-May-2015 Page 2 of 8 closed. Ground/bond container and receiving equipment. Use explosion-proof electrical/ventilating/lighting/…/equipment. Use only non-sparking tools. Take precautionary measures against static discharge. In case of fire: Use fire extinguishers suitable for Classes B, C, or E for extinction. Avoid breathing vapors. Use only outdoors or in a well-ventilated area. Wear protective gloves/protective clothing/eye protection.
PAGE 3
Armaflex 520 BLV Contact Adhesive 12-May-2015 Page 3 of 8 Ingestion : May cause irritation to the mouth, throat, and stomach. Symptoms may include abdominal pain, nausea, vomiting, and diarrhea. This material can get into the lungs (aspiration) during swallowing or vomiting. Small amounts in the lungs can cause chemical pneumonitis, possibly leading to chronic lung dysfunction or death. Effects of long-term (chronic) exposure : Chronic exposure may cause drying, cracking, and defatting of the skin.
PAGE 4
Armaflex 520 BLV Contact Adhesive 12-May-2015 Page 4 of 8 flush into surface water or sanitary sewer system. Notify the appropriate authorities as required. Incompatible materials : See Section 10. Special spill response procedures : If a spill/release in excess of the EPA reportable quantity is made into the environment, immediately notify the national response center in the United States (phone: 1-800-424-8002). US CERCLA Reportable quantity (RQ): Acetone (5000 lbs / 2270 kg).
PAGE 5
Armaflex 520 BLV Contact Adhesive 12-May-2015 Page 5 of 8 be sought from glove suppliers regarding the glove’s breakthrough time for the ingredients listed in Section 3. Eye / face protection : Chemical goggles are recommended. A full face shield may also be necessary. Other protective equipment : Full chemical-resistant protective clothing should be used whenever splashing is anticipated. An eyewash station and safety shower should be made available in the immediate working area.
PAGE 6
Armaflex 520 BLV Contact Adhesive 12-May-2015 Acrylonitrile/Butadiene copolymer p-tert-butylphenolFormaldehyde resin 6,6'-di-tert-butyl-2,2'methylene-di-p-cresol Page 6 of 8 9003-18-3 N/Av > 2000 N/Av 25085-50-1 N/Av N/Av N/Av 119-47-1 N/Av > 10000 N/Av Calculated Acute Toxicity Estimates for the Product Inhalation : > 50 mg/L Oral : > 4000 mg/kg Dermal : > 20,000 mg/kg Carcinogenic status Reproductive effects : No components are listed as carcinogens by ACGIH, IARC, OSHA or NTP.
PAGE 7
Armaflex 520 BLV Contact Adhesive 12-May-2015 TDG UN 1133 Page 7 of 8 ADHESIVES containing flammable liquid (Acetone) 3 II TDG Additional Information May be shipped as Limited Quantity when transported in containers no larger than 5.0 Litres; in packages not exceeding 30 kg gross mass. Refer to TDG Part 1: 1.11, 1.17, 1.33; and Schedule 1. 49 CFR/DOT UN 1133 49 CFR/DOT Additional Information May be shipped as Limited Quantity when transported in containers no larger than 5.
PAGE 8
Armaflex 520 BLV Contact Adhesive 12-May-2015 Page 8 of 8 Inh: Inhalation N/Av: Not Available N/Ap: Not Applicable NIOSH: National Institute of Occupational Safety and Health NTP: National Toxicology Program OSHA: Occupational Safety and Health Administration PEL: Permissible exposure limit RCRA: Resource Conservation and Recovery Act SARA: Superfund Amendments and Reauthorization Act STEL: Short Term Exposure Limit TDG: Canadian Transportation of Dangerous Goods Act & Regulations TLV: Threshold Limit Va