User Manual

ManualsBrandsARGO ManualsOtherFuel System

Argo Service Manual Fuel System

Ontario Drive & Gear Limited www.argoutv.com

PH.(519)- 662-2840 FAX (519)- 662-2421

Fuel System Argo Service Manual

FS-1 FS-1

Fuel System

Table of Contents

General Instructions............................................................................. FS-2

Fueling the Vehicle................................................................................ FS-3

Fuel Filter and Fuel Pump................................................................... FS-5

Vented Fuel System............................................................................... FS-6

Removing the Fuel Tank....................................................................... FS-6

Fuel Tank Assembly.............................................................................. FS-7

Vented Fuel System............................................................................... FS-4

Installing the Fuel Tank........................................................................ FS-9

Inspecting the Fuel Tank and Fuel Line..............................................FS-10

Electronic Fuel Injection System

http://www.kohlerengines.com/onlinecatalog/pdf/tp_2527.pdf

SECTION FS

Summary of content (12 pages)

PAGE 1
Argo Service Manual Fuel System SECTION FS Fuel System Table of Contents General Instructions............................................................................. FS-2 Fueling the Vehicle................................................................................ FS-3 Fuel Filter and Fuel Pump................................................................... FS-5 Vented Fuel System............................................................................... FS-6 Removing the Fuel Tank......
PAGE 2
Fuel System General Instructions Argo Service Manual IMPORTANT Detailed engine service and maintenance is NOT included in this service manual. For a complete guide of Kohler service instruction refer to Kohler Engine Service Manual TP-2527-A available from an authorized Kohler dealer or available for download from their website at www.kohlerengines.
PAGE 3
Argo Service Manual Fuel System Fueling the Vehicle WARNING Gasoline is extremely flammable and can explode under certain conditions. Do not add fuel while the engine is running or hot. If fuel is spilled in, on or around the vehicle, wipe it up immediately. Flush out any fuel spilled in the vehicle with water and allow it to drain out through the drain plug holes. Do not smoke when filling the fuel tank. Use clean, fresh, unleaded gasoline in all models of the ARGO.
PAGE 4
Fuel System Argo Service Manual CAUTION Never use untreated gasoline that has been stored for more than 45 days. Stale gasoline can cause deposits to form in the fuel lines and carburetor. These deposits clog the fuel system and cause engine starting and operating problems. When storing the ARGO for 45 days or more, use ARGO Part No. 127-77 Fuel Stabilizer to treat fuel in the fuel tank and fuel containers.
PAGE 5
Argo Service Manual Fuel System Fuel Filter - Avenger and HDi HDi and Avenger EFI models have 1 fuel filter, located in the rear compartment at the fuel tank (Part No. 24 050 03). Figure 6-6. Figure 6-6. HDi and Avenger EFI fuel filter location. Fuel Pump and Pressure Regulator Configuration (HDi and Avenger EFi) Figure 6-6a. Avenger 700 fuel filter location. Replace the Kohler high pressure fuel filter after every 1000 hours of operation or once a year.
PAGE 6
Fuel System Argo Service Manual Vented Fuel System - Prior to Serial # 31239 The fuel system is vented through a special hose connected to the filler neck assembly that runs along the upper body to a fitting at the left rear. From Serial # 31239 Newer models have vent line connected to allow vacuum purge port on the engine via a roll over valve, fumes are burned in the engine. California models also include a carbon canister to collect fumes when vehicle is not running.
PAGE 7
Argo Service Manual Fuel System 5. Remove the battery. 6. Drill out the 11 rivets that secure the tool box to the seat frame and remove. 7. Disconnect the fuel line at the pickup tube on the fuel tank. 8. Remove the tank from the vehicle. The tank will come forward into the drivers compartment (earlier Avenger Models). Photo 1 & 2 Later models/HDi may be more easily removed into the rear compartment. Photo A NOTE Fill neck hose must be disconnected.
PAGE 8
Fuel System Argo Service Manual NOTE Vehicles manufactured prior to 25950 utilize a PICKUP, FUEL, 1/4 x 11.75 that threads into the top portion of the fuel tank. Vehicles manufactured from 25950 utilize PICKUP, FUEL, 5/16" x 11.75" G Dapco grommet style pickup tube. Fuel Tank Assembly IMPORTANT Before installing the fuel tank, ensure all foreign matter has been removed from inside the tank using compressed air. CAUTION Compressed air is dangerous.
PAGE 9
Argo Service Manual Fuel System Photo 5 Photo 6 Photo 7 Avenger EFI & HDi Models: Vehicles Prior to Serial Number 31036 4. Apply teflon tape to the Return Tube and thread it to the tank at the location illustrated in Photo 6. Avenger EFI & HDi Models: Vehicles From Serial Number 31036 4a. Insert the grommet (small end first) into the unthreaded hole. 4b. Coat I.D of Grommet with lubricant. Photo 4 4c. Slowly press the Fuel Pickup Return Tube through the grommet.
PAGE 10
Fuel System Argo Service Manual Carburated Avengers Only: Vehicles Prior to Serial Number 31036 5. Apply teflon tape to the Nylon Plug and install it securely to threaded hole of the tank as illustrated in Photo 7. 5a. Insert the grommet (small end first) into the unthreaded hole. 5b. Coat I.D of Grommet with lubricant. Photo 4 5c. Slowly press the Push In Plug through the grommet. Vehicles manufactured prior to 25950: 1.
PAGE 11
Argo Service Manual Fuel System Inspecting the Fuel Tank and Fuel Line WARNING Leakage in the fuel system is very dangerous! A spark or open flame can ignite gas line fumes, causing serious injury or death. Extensive vehicle damage will also occur. Regular inspection of the fuel tank and fuel line is essential to personal safety and good vehicle performance.
PAGE 12
Fuel System Ontario Drive & Gear Limited PH.(519)- 662-2840 FAX (519)- 662-2421 Argo Service Manual FS-12 www.argoutv.