Operator`s manual
46
SECTION 7
MAINTENANCE INFORMATION
The intervals shown on the schedule are based on average operating conditions. Vehicles which are subjected to
severe use and wet or dusty conditions will require more frequent servicing. Use only Argo replacement parts to
ensure safe operation of the vehicle and to comply with the warranty coverage.
We strongly recommend that an Argo Dealer perform a complete check-over of your vehicle after the initial
20 hours of operation, then once each year. This will reduce maintenance costs over the life of your vehicle.
Check coolant level (Kohler engine)
Check fan belt tension (Kohler engine)
Check fuel level
Check tire ination
Check twist grip throttle operation
Check handlebar travel
Check engine intake/exhaust for obstructions
Check that drain plugs are in place
Check engine oil level
Change engine oil & oil lter
- Kohler
- Briggs & Stratton
Check transmission oil level
Change transmission oil
Clean air pre-cleaner (Briggs only)
Check clean/replace air lter
Replace fuel lter (Kohler high pressure every 1000 hrs.)
Service driver & driven clutch
Lubricate drive chains
Remove, clean & lube drive chains
Lubricate idler chains (if equipped)
Remove, clean & lube idler chains (if equipped)
Lubricate outer axle bearings
Lubricate inner axle bearings
Lubricate output shafts
Lubricate idler bearings
Check battery uid level & caps
Clean battery terminals & connections
Clean battery
Clean, adjust/replace spark plugs
Check the drive belt
Check nylon sliders - driven clutch
Check sliders - chain take-up system
Check & adjust idler chains
Inspect brake pads
Inspect/adjust emergency/parking brake
Check hydraulic brake uid level/condition
Check fuel tank connections/lines
Inspect wiring harness
Tighten bearing extension bolts
Clean out spark arrester
X
X
X 2.2
X 7.2.6
X 2.2
X 2.2
X 2.2
X 5.6
X 6.1.1
X X 6.1.3
X X 6.1.3
X X 6.2.1
X X 6.2.2
X 6.3.1
X 6.3.1
X 6.3.2
X 6.4.2
X 6.4.3
X 6.4.3
X 6.4.5
X 6.4.5
X 6.4.6
X 6.4.9
X 6.4.8
X 6.4.7
X 7.1.2
X 7.1.2
X 7.1.2
X 7.1.4
X 7.2.1
X 7.2.2
X X 7.2.4
X X 7.2.5
X 7.3.4
X 7.3.5
X 7.3.2
X
X
X X 7.2.8
X 7.1.5
BEFORE
EACH
USE
AFTER INITIAL
EVERY
SECTION
REF.
2hrs. 8hrs. 20hrs. 10hrs. 25hrs. 50hrs. 100hrs. 250hrs.