Operator`s manual

23
SECTION 6
OIL, FILTER AND LUBRICATION INFORMATION
Overlling may result in oil being forced out the breather
hole that could contaminate the brake pads and lead to brake
failure.
Relling the Transmission - HDi and HD
Install the drain plug. Remove the ll/vent plug located on
the top of the transmission. Fill the transmission with 80W90
Gear Lube HYPO-C. Fill the transmission until the sight
glass is half full. For Oil capacity see Oil Capacity Chart
(Figure 6-5).
Figure 6-5. Transmission Oil Capacity
6.3 FILTER INFORMATION
6.3.1 Air Filter
All Briggs and Stratton engines are equipped with a foam
precleaner and dry paper air lter element housed in an air
cleaner assembly attached to the carburetor.
Wash and oil the precleaner after every 25 hours of operation
or more often under extremely dusty or dirty conditions.
Check the paper air lter element every 100 hours of operation
or more often under extremely dusty or dirty conditions.
AVENGER and HDi Models
The Kohler Aegis engine is equipped with a heavy duty high
density paper air cleaner element surrounding a canister style
inner element. Cleaning is not recommended, each element
should be replaced when dirty. See Figure 6-5a.
Figure 6-5a. Air Cleaner Element and Inner Element.
For instructions to remove, clean and replace the air lter
components, refer to the air cleaner section of the engine
Owners Manual.
6.3.2 Fuel Filter - Avenger and HDi
All models of the ARGO are equipped with an in-line fuel lter.
HDi and Avenger EFI models have 1 fuel lter, located in the rear
compartment at the fuel tank (Part No. 24 050 03). Figure 6-6.
Figure 6-6. HDi and Avenger EFI fuel lter location.
Figure 6-6a. Avenger 700 fuel lter location.
Replace the Kohler high pressure fuel lter after every 1000
hours of operation or once a year. To replace the lter, loosen
the gear clamps with a standard screw driver and pull the rub-
ber fuel lines off of the lter. Install the new lter with the
ow arrow pointing toward the engine. Tighten the clamps
securely. Start the engine and check for fuel leaks.
6.3.3 Fuel Filter - Avenger 700, 700 HD, 6x6 HD and
Frontier
On all other Argo models the fuel lter is located at the engine
(ARGO Part No. 125-64). Replace every 250 hours or once
a year.