Operating instructions

ManualsBrandsAPW Wyott ManualsKitchen AppliancePOPCONRN MPC-1A

Phone: +1

Fax: +1 (307) 637-8071

Toll Free: +1 (800) 752-0863

Website: www.apwwyott.com

E-mail: info@apwwyott.com

(307) 634-5801

INSTALLATION

AND

OPERATING

INSTRUCTIONS

INTENDED FOR OTHER THAN HOUSEHOLD USE

RETAIN THIS MANUAL FOR FUTURE REFERENCE

UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES

APW WYOTT

P.O. Box 1829

Cheyenne, WY 82003

This equipment has been engineered to provide you with year-round dependable service when used

according to the instructions in this manual and standard commercial kitchen practices.

WARNING: Improper installation, adjustment, alteration, service or maintenance can

cause property damage, injury or death. Read the Installation, Operating and

Maintenance Instructions thoroughly before installing or servicing this equipment.

IMPORTANT FOR FUTURE REFERENCE

Please complete this information and retain this manual for the life of the equipment. For

Warranty Service and/or Parts, this information is required.

Model Number Serial Number Date Purchased

MERCHANDISERS

Models: DS-1A, DR-1A, BW-1A, MPC-1A, PC-1A, NC-1A, PDM

Model DR-2A Hot Dog Broiler

With Optional BH-1A Bun Holder

Summary of content (12 pages)

PAGE 1
R INSTALLATION AND OPERATING INSTRUCTIONS roiler ot Dog B older H A -2 R D Bun H Model al BH-1A n o ti p O With MERCHANDISERS Models: DS-1A, DR-1A, BW-1A, MPC-1A, PC-1A, NC-1A, PDM INTENDED FOR OTHER THAN HOUSEHOLD USE RETAIN THIS MANUAL FOR FUTURE REFERENCE UNIT MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment. For Warranty Service and/or Parts, this information is required.
PAGE 2
APW Wyott takes pride in the design and quality of our products. When used as intended and with proper care and maintenance, you will experience years of reliable operation from this equipment. To ensure best results, it is important that you read and follow the instructions in this manual carefully. Installation and start-up should be performed by a qualified installer who thoroughly read, understands and follows these instruction.
PAGE 3
CONTENTS Safety Precautions 2 General Information & Troubleshooting 3 DS-1A Mr. Frank Display Steamer 4 DR-1A Mr. Frank Display Broiler w/BW-1A Bun Warmer 4 MPC-1A Deluxe Popcorn Popper & PC-1A Deluxe Clearview Popcorn Popper 5 NC-1A Nacho Chip Cabinet 6 PDM Pretzel Display Merchandiser 6 Wiring Diagram 7 Parts List & Exploded View 8 Warranty 11 LOCATION OF DATA PLATE The data plate for the warming shelf is located on the back of the unit.
PAGE 4
General Operating Instructions: 1. All foodservice equipment should be operated by trained personnel. 2. Do not allow your customers to come in contact with any surface labeled “CAUTION HOT.” 3. Where applicable, never pour cold water into dry heated units. 4. Where applicable, do not cook, warm or hold food directly in liner pans (well pans). Always use steam table pans/insets, etc. 5. Never hold food below 150°F (66°C). General Cleaning Instructions: 1.
PAGE 5
4. 5. Operations: 1. 2. 3. 4. 5. 6. 7. 8. always face operator. Slide drip pan into cabinet under the basket assembly. If optional bun warmer is used, place warmer into opening on top of broiler. Follow general operating instructions on page 4. Switch on unit. Set infinite control to “HI” position to begin broiling. Load each basket with up to 4 hot dogs. Use “Load/Unload” push button. Heat up time will depend on the size and temperature of the hot dogs when loaded into the baskets.
PAGE 6
Suggestions: 1. Keep access doors open when popping to reduce cabinet moisture. 2. Use POWER/DISPLAY switch to warm and display popped corn. Cleaning/Daily Cleaning: 1. Follow general cleaning instructions on page 4. 2. To prevent build-up of excess oil and salt, clean daily when kettle is still warm. CAUTION: Allow sufficient cool down time before removing kettle for cleaning. Do NOT immerse kettle in water. 3. Pull spring clip to remove stirrer from drive shaft.
PAGE 7
WIRING DIAGRAM DR-1A, DR-2A LAMPS 240V SINGLE PHASE HEATING ELEMENT LAMPS INDICATOR LIGHT P L1 L2 H1 H2 GEAR MOTOR INFINITE CONTROL LOAD/UNLOAD SWITCH ON/OFF SWITCH TERMINAL BLOCK 7 240V SINGLE PHASE
PAGE 8
R P.O. Box 1829 Cheyenne, WY 82003 DR-1A, DR-2A, BH-1A Display Hot Dog Broiler Phone: +1 (307) 634-5801 Fax: +1 (307) 637-8071 Toll Free: +1 (800) 752-0863 Website: www.apwwyott.com E-mail: info@apwwyott.com HOT DOG ROASTER DR-1A & DR-2A Item Part No.e Description Item Part No.
PAGE 9
DR-1A, DR-2A, BH-1A R Display Hot Dog Broiler P.O. Box 1829 Cheyenne, WY 82003 BUN HOLDER BH-1A Phone: +1 (307) 634-5801 Fax: +1 (307) 637-8071 Toll Free: +1 (800) 752-0863 Website: www.apwwyott.com E-mail: info@apwwyott.com HOT DOG ROASTER DR-1A 40 33 41 36 6 7 42 10 39 9 38 37 12 11 30 13 31 8 5 22 14 3 24 23 2 1 19 18 29 21 17 27 26 28 25 4 32 15 16 34 35 Page 3 of 4 Note: When ordering, ALWAYS specify Part #, Model #, Serial #, Voltage & Phase.
PAGE 10
NOTES: 10
PAGE 11
APW WYOTT EQUIPMENT LIMITED WARRANTY APW Wyott Foodservice Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the following conditions: This warranty applies to the original owner only and is not assignable. Should any product fail to function in its intended manner under normal use within the limits defined in this warranty, at the option of APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency.
PAGE 12
R Phone: Fax: Toll Free: Website: E-mail: +1 (307) 634-5801 +1 (307) 637-8071 +1 (800) 752-0863 www.apwwyott.com info@apwwyott.com APW WYOTT P.O.