Appleton Grp LLC 9377 W. Higgins Road Rosemont, IL USA 60018 1 (847) 268-6000 IMPORTANT: EMERGENCY CONTACT INFORMATION IS ENCLOSED. Dear Customer, Enclosed please find the Safety Data Sheet (SDS) for the Appleton® KWIKO-A and Fiber Filler. This product is purchased from the manufacturer by Appleton and is distributed with no modification other than packaging, as applicable. Questions regarding application and use may be directed to Appleton Technical Support.
Kwiko-A Sealing Cement SAFETY DATA SHEET (Complies with OSHA 29 CFR 1910.
2.2d Precautionary statements Do not handle until all safety precautions have been read and understood. Wear impervious gloves, such as nitrile. Wear eye protection, and protective clothing. Do not eat, drink or smoke when using this product. Wash thoroughly after handling. Use only in a well-ventilated area. Do not breathe dust. If swallowed: Rinse mouth. Do NOT induce vomiting. If inhaled: Remove person to fresh air and keep comfortable for breathing.
Signal Word DANGER! SECTION III - HAZARDOUS INGREDIENTS/IDENTITY INFORMATION Hazardous Components Sand, Silica, Quartz Portland Cement Fly Ash CAS No. 14808-60-7 65997 15 1 68131-74-8 % by Weight 40-70* 10-30* 5-10* *The concentrations ranges are provided due to batch-to-batch variability. None of the constituents of this material are of unknown toxicity. SECTION IV – FIRST AID MEASURES 4.1 Description of the first-aid measures General information: After inhalation: Remove person to fresh air.
Eye Contact: Causes serious eye damage. Symptoms may include discomfort or pain, excess blinking and tear production, with marked redness and swelling of the conjunctiva. Ingestion: May be harmful if swallowed. Ingestion may cause discomfort and/or distress, nausea or vomiting. 4.3 Indication of immediate medical attention and special treatment needed: Immediately seek medical advice or attention if symptoms are significant or persist. SECTION V - FIRE FIGHTING MEASURES 5.
Further information about storage conditions: Keep out of the reach of children. Keep container tightly closed and prevent exposure to humidity. Do not allow water to contact the product until time of use to preserve product utility. SECTION VIII – EXPOSURE CONTROL MEASURES / PERSONAL PROTECTION 8.1 Components with limit values that require monitoring at the workplace: Hazardous Components CAS No. PEL (OSHA) TLV (ACGIH) 3 mg/M mg/M3 Silica Sand, crystalline 14808-60-7 0.1 0.
Flash point: Not applicable Auto igniting: Product is not self-igniting Vapor pressure at 21°C (70°F) Not available Density at 25°C (77 °F): 2.6 to 3.15 Solubility in / Miscibility with Water: Insoluble VOC content: 0 g/L VOC SECTION X – STABILITY AND REACTIVITY 10.1 Reactivity No dangerous reaction known under conditions of normal use. 10.2 Chemical stability Stable under normal storage conditions. Keep in dry storage. 10.
Ingestion: Harmful if swallowed. Ingestion may cause discomfort and/or distress, nausea or vomiting. 11.3 Delayed, immediate and chronic effects of short-term and long-term exposure Short Term Skin Corrosion/Irritation: Causes severe skin burns. Serious Eye Damage/Irritation: Causes severe eye damage. Respiratory Sensitization: Not available Skin Sensitization: May cause an allergic skin reaction. Specific Target Organ Toxicity-Single Exposure: (Category 3) May cause respiratory irritation.
The packaging and material may be land filled; however, material should be covered to minimize generation of airborne dust. This product is not classified as a hazardous waste under the authority of the RCRA (40CFR 261) or CERCLA (40CFR 117&302). Disposal must be made in accordance with local, state and federal regulations. 13.2 Other disposal considerations Uncleaned packaging Recommendation: Disposal must be made in accordance with local, state and federal regulations.
No chemicals in this material are subject to the reporting requirements of SARA Title III, Section 302, 311, 312 or 313. RCRA: Crystalline silica (quartz) is not classified as a hazardous waste under the Resource Conservation and Recovery Act, or its regulations, 40 CFR §261 et seq. CERCLA: Crystalline silica (quartz) is not classified as a hazardous substance under regulations of the Comprehensive Environmental Response Compensation and Liability Act (CERCLA), 40 CFR §302.
SECTION XVI – OTHER INFORMATION Last Updated: June 11, 2015 NOTE: The information and recommendations contained herein are based upon data believed to be correct. However, no guarantee or warranty of any kind, express or implied, is made with respect to the information contained herein. We accept no responsibility and disclaim all liability for any harmful effects which may be caused by exposure to silica contained in our products. Prepared by The QUIKRETE® Companies Phone (800) 282-5828 www.QUIKRETE.
Kwiko Fiber Filler SAFETY DATA SHEET (Complies with OSHA 29 CFR 1910.
Wash thoroughly after handling. If swallowed: Rinse mouth. Do NOT induce vomiting. If inhaled: Remove person to fresh air and keep comfortable for breathing. If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If on skin (or hair): Remove immediately all contaminated clothing and wash before re-use. Rinse skin or hair with water. If significant skin irritation or rash occurs: get medical advice or attention.
SECTION IV – FIRST AID MEASURES 4.1 Description of the first-aid measures General information: After inhalation: Remove person to fresh air. If breathing is difficult, administer oxygen. If not breathing, give artificial respiration. In case of unconsciousness, place patient stably in side position for transportation. After skin contact: Wash skin with cool water and pH-neutral soap or a mild detergent. If significant skin irritation or rash occurs: get medical advice or attention.
6.2 Methods and material for containment and cleaning up: Do not allow to enter sewers/ surface or ground water. Dispose of unwanted materials and containers properly in accordance with all regulations. SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND STORAGE 7.1 Handling Precautions for safe handling: Ensure good ventilation/exhaustion at the workplace. appropriate PPE (See section 8). Wear 7.2 Storage Requirements to be met by storerooms and receptacles: No special requirements.
Respiratory protection: Not generally required under normal usage.
Eye Contact: Causes eye irritation. Ingestion: Harmful if swallowed. Ingestion may cause discomfort and/or distress, nausea or vomiting. 11.
The packaging and material may be land filled. This product is not classified as a hazardous waste under the authority of the RCRA (40CFR 261) or CERCLA (40CFR 117&302). Disposal must be made in accordance with local, state and federal regulations. 13.2 Other disposal considerations Uncleaned packaging Recommendation: Disposal must be made in accordance with local, state and federal regulations. Recommended cleansing agent: Water, if necessary with cleansing agents.
15.3 State Right to Know Laws Not applicable. 15.4 Global Inventories DSL All components of this product are on the Canadian DSL list. 15.5 NFPA Ratings SECTION XVI – OTHER INFORMATION Last Updated: January 5, 2016 NOTE: The information and recommendations contained herein are based upon data believed to be correct. However, no guarantee or warranty of any kind, express or implied, is made with respect to the information contained herein.