User Guide

6 Page
SAFETY GUIDELINES
SAFETY DEFINITION
GENERAL
1. Follow all local codes, or in the absence of local codes, follow the current edition of the National Fuel Gas Code:
ANSI Z223.1/NFPA 54 in the USA or B149.1, Natural Gas and propane installation code in Canada.
2. Properly ground the unit in accordance with all local codes or in the absence of local codes, with the current
edition of the National Electrical Code: ANSI/NFPA 70 in the USA or CSA standard C22.1 Canadian Electrical
Code Part 1 in Canada.
3. Carefully plan where you intend to install the water heater. Please ensure:
 Your water heater will have enough combustion air and proper ventilation.
 Locate your heater where water leakage will not damage surrounding areas. (Please refer to p. 8.)
4. Check the rating plate for the correct GAS TYPE, GAS PRESSURE, WATER PRESSURE and ELECTRIC RATING. If
this unit does not match your requirements, do not install and consult with the manufacturer. The water
heater is configured only for use with Natural Gas at the factory. If the appliance is used with propane gas,
conversion to propane gas with an included conversion kit (LP Conversion Kit: 100281154) is required. The
conversion must be done by a qualified service agent or a gas utility service person in accordance with this
instruction and all codes and requirements of the authority having jurisdiction. Failure to follow instructions
could result in property damage, serious personal injury, or death. The agent performing this work assumes
responsibility for this conversion. (Refer to the gas conversion leaflet.)
5. If any problem should occur, turn off all hot water fixtures and turn off the gas. Then call a trained technician,
the gas company, or the manufacturer.
WARNING
 Water temperatures over 125 °F (52 °C) can cause severe burns instantly or death from
scalding. The water temperature is set at 120 °F (50 °C) from the factory to minimize any
scalding risk. Before bathing or showering always check the water temperature.
 Do not store or use gasoline or other flammables, vapors, or liquids in the vicinity of this
appliance.
 Do not reverse the water and/or gas connections as this will damage the gas valves and
can cause severe injury or death. Follow the diagram on p. 20 when installing your water
heater.
 The conversion to propane must be done by a qualified service agent or a gas utility
serviceman in accordance with this instruction and all codes and requirements of the
authority having jurisdiction. Failure to follow instructions could result in serious injury
or property damage. The qualified agent performing this work assumes responsibility
for this conversion.
 Do not use this appliance if any part has been in contact with or been immersed in water.
Immediately call a qualified installer or service agency to replace a flooded water heater.
Do not attempt to repair the unit. It must be replaced.
 Failure to observe these warnings could result in severe personal injury or death.
Safety Guidelines
Installaon Manual
WARNING
Indicates an imminently hazardous situation which, if not avoided, could result in death or seri-
ous injury.
CAUTION
Indicates an imminently hazardous situation which, if not avoided, could result in minor or
moderate injury.
Indicates an imminently hazardous situation which, if not avoided, will result in death or serious
injury.
DANGER
Indicates information considered important but not hazard related.
NOTICE