SPECIAL NOTICE This product is now licensed to Anodyne Electronics Manufacturing (AEM) from Northern Airborne Technology (NAT). AEM is responsible for all matters related to this product, including sales, support and repair services. Please note the transition to convert product manuals and supporting documentation is an ongoing process and is being addressed on an ‘as needed’ basis. All references to NAT product part numbers (and associated images) are equivalent to AEM product part numbers.
SM09-2 AA83-001 InterMUSIC™ Stereo Intercom System Serial No. 2938 and below INSTALLATION AND OPERATION MANUAL REV 5.00 April 17, 2012 Anodyne Electronics Manufacturing Corp. 15-1925 Kirschner Road Kelowna, BC, Canada. V1Y 4N7 Telephone (250) 763-1088 Facsimile (250) 763-1089 Website: www.aem-corp.com © 2012 Anodyne Electronics Manufacturing Corp. (AEM), All Rights Reserved CONFIDENTIAL AND PROPRIETARY TO ANODYNE ELECTRONICS MANUFACTURING CORP.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual COPYRIGHT STATEMENT © 2012 Anodyne Electronics Manufacturing Corp. (AEM), All Rights Reserved This publication is the property of AEM and is protected by Canadian copyright laws. No part of this document may be reproduced or transmitted in any form or by any means including electronic, mechanical, photocopying, recording, or otherwise, without the prior written permission of AEM.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual Prepared By: Checked By: Tony Pearson Designer Apr 17, 2012 Approved By: Tom Betzelt Product Support Manager May 28, 2012 Loen Clement Designer May 24/12 The status of this installation and operation manual is controlled by issue shown on the title page. The status of each section is controlled by revision shown in the footer of each page.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual Table of Contents Section Title 1.0 Description 1.1 1.2 1.3 1.3.1 1.3.2 1.4 1.4.1 1.4.2 1.4.3 Introduction Purpose of Equipment Features Stereo & Intercom Special Features Communication Functions Specifications Electrical Specifications Physical Specifications Environmental Specifications 2.0 Installation 2.1 2.2 2.2.1 2.3 2.3.1 2.3.2 2.3.3 2.3.4 2.3.5 2.3.6 2.3.7 2.3.8 2.3.9 2.4 2.5 2.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual Section 1.0 Description 1.1 Introduction This manual contains information on the AA83-001 InterMUSIC™. All derivative products will be covered by manual supplements, which can be obtained from AEM as required. Information in this section consists of purpose of equipment, features and specifications. 1.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual 1.4 Specifications 1.4.1 Electrical Specifications Input Power +11 to +32 Vdc. Nominal 14/28 Vdc systems Supply Current 0.4A max.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual 1.4.2 Physical Specifications Dimensions excluding front panel: 1.4.3 Height 1.30” (33.0 mm) max. Depth 5.60” (142.2 mm) max Width 2.60” (66.0 mm) max Weight 0.60 lbs (283.5g) excluding external hardware Mounting Horizontal or vertical through-panel mounting Environmental Specifications Temperature: Operating Storage -40˚C.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual Section 2.0 Installation 2.1 Introduction Information in this section consists of: unpacking and inspection procedures, installation procedures, post-installation checks, and installation drawings. 2.2 Unpacking and Inspection Unpack the equipment carefully. Inspect the unit visually for damage due to shipping and report all such claims immediately to the carrier involved.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual 2.3.3 Cabling and Wiring All unshielded wire should be to MIL-W-22759 or equivalent. For shielded wire applications, use Tefzel MIL-C-27500 shielded wire with solder sleeves (for shield terminations) to make the most compact and easily terminated interconnect. Follow the wiring diagrams in Section 2.6 as required. Allow 3 inches from the end of the wire to the shield termination to allow the hood to be easily installed.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual The internal adjustments are located along the sides of the unit and are as follows: 2.3.5.1 ICS, RX, and MUSIC BAL These potentiometers are used to adjust the headset stereo balance. Note: 2.3.5.2 The balance adjustment pots permit signals to be shifted in the user's acoustic listening space so that tower transmissions appear to come from one area, and intercom from another.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual To gain access to the jumpers, remove the cover from the AA83-001. Remove the top PCB by removing three pan-head screws and carefully lifting it straight up. When reassembling the unit ensure the pins and connector are aligned properly before screwing the PCB down. 2.3.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual 2.3.8.1 Voltage/resistance checks Do not attach the AA83-001 until the following conditions are met. Check the following: a) Check P101, pin <1> for +9 to +32 Vdc relative to ground. b) Check P101, pin <16> for continuity to ground (less than 0.5 :). c) Check P101, pins <11> and <12> for continuity to ground (less than 0.5 :) when the relevant ICS switch is keyed.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual 2.4 Continued Airworthiness Maintenance of the AA83-001 is ‘on condition’ only. Periodic maintenance of this product is not required. 2.5 Accessories Required Installation kit p/n AA83-IKC is required to complete the installation.
Confidential and Proprietary to NAT
Confidential and Proprietary to NAT
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual Section 3.0 Operation 3.1 Introduction Information in this section consists of the functional and operational procedures for the AA83-001 InterMUSIC™ stereo intercom. 3.2 General The AA83-001 InterMUSIC™ is a stereo intercom system that supports a pilot, copilot and two passengers.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual 3.3 Controls and Indicators ICS VOL (Inner) PILOT VOX (Outer) Mode Switch 3.3.1 MUSIC VOL (Inner) COPILOT VOX (Outer) Annunciator ICS VOL/VOX The ICS VOL/PILOT VOX control is a fluted concentric rubber knob on the left side of the front panel. The inner (front) knob is the ICS VOL control, which is used to set Intercom volume. It is at minimum volume when fully counter-clockwise (ccw).
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual 3.3.4 VOX Operation The VOX control is used to set the level of audio required to activate the microphones. The AA83-001 provides three modes of intercom operation, selected by the position of the VOX control. LIVE ICS When the VOX control is positioned fully ccw, the relevant mics will be live, and any sound picked up will be processed by the ICS system (hot mic).
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual 3.3.5.3 Tie/Split Operation The MODE switch has one further position, which can be used in expanded systems for more complex audio circuits. If an outboard AA82 has been installed (or some other AEM system with tie line capability), then this switch will open and close the tie line output to create common or split intercom circuits with the external system.
AA83-001 InterMUSIC™ Stereo Intercom System SM09-2 Installation and Operation Manual 3.3.7 Muting Explanation When transmitting, any music will be muted quickly, and will slowly return when transmission is completed. Music will also be muted when ICS or RX functions are active. The degree of muting is set via the MUSIC MUTE adjustment explained in the installation section of this manual. The relative volume of the music can be changed from the front panel by the knob marked with a musical note.
