8000842-01 Assembly Instructions Type 960 Class I & II .96 Meter Antenna System Type 123 Class I & II 1.2 Meter LFL Antenna System with Factory Assembled Az/El Cap Mount DO NOT DISCARD CONTENTS One Company. A World of Solutions. The product in this packaging was placed in the market after August 13, 2005. Its components must not be discarded with normal municipal or household waste. Contact your local waste disposal agency for recovery, recycling, or disposal instructions.
DATE DESCRIPTION REV. 1/06 ECN9007200 Rev A 8/06 ECN9007484 Rev B HARDWARE SORTER BOLT, PLOW, SPECIAL M8 x 1.25 x 56 ITEM 1 BOLT, PLOW, SPECIAL M8 x 1.25 x 91 SHEET # 14 ITEM 1 VSAT ANTENNA/MOUNT/LNB LIMITED TWELVE (12) MONTH WARRANTY This ANDREW CORPORATION® equipment is warranted to be free from defects in material and workmanship under normal use and service.
PARTS LIST IMPORTANT!!! 96cm CLASS II - MEDIUM DUTY CLASS I - LIGHT DUTY SYSTEM (1.2m SHOWN) 12 INSTALLATION OF THIS PRODUCT SHOULD BE PERFORMED ONLY BY A PROFESSIONAL INSTALLER AND IS NOT RECOMMENDED FOR CONSUMER D.I.Y. (DO-IT-YOURSELF) INSTALLATIONS. 9 13 10 3 11 DANGER!!! 20 WATCH FOR WIRES! YOU CAN BE KILLED IF THIS PRODUCT COMES NEAR POWER LINES. Installation of this product near power lines is dangerous. For your own safety, follow these important safety rules. 1.
GROUND POLE INSTALLATION (96cm System) AZ-EL MOUNT WITH M8 INSERT AND SET SCREW 2.88" or 3.00" O.D. 2.88" or 3.00" O.D. IMPORTANT L ANT C 1" to 2" SLOPE FOR WATER RUN OFF 36.4" 72" 41.5" WATER RUN OFF NOTE: GRADE 72" 50" depth may be increased, concrete and length of rebar will increase accordingly. GRADE M8 x 20 mm Hex Head Set Screws are recommended for schedule 40 (.203 wall) mast and NOT RECOMMENDED for mast with a wall thickness less than 10 ga (.
GROUND POLE INSTALLATION (1.2m System) APPENDIX B 1.2m Antenna Survival Windloads at 125 MPH Velocity 2.88" or 3.00" O.D. 2.88" or 3.00" O.D. L ANT C IS AM BE AX 1" to 2" SLOPE FOR 35.8" NOTE: WATER RUN OFF 72" o GRADE 72" 50" depth may be increased, concrete and length of rebar will increase accordingly. GRADE 16.97 OFFSET MECHANICAL AXIS (NORMAL TO ANTENNA FACE) FH 1" to 2" SLOPE FOR WATER RUN OFF 35.8" 40.9" (SEE 50" NOTE) 40" 2" APPROX. #3 REBAR x DIA.
ASSEMBLY AND INSTALLATION INSTALLING AZ/EL CAP MOUNT ONTO POLE TOP BRACKET APPENDIX A The AZ/EL Cap is factory preassembled, therefore, no assembly is required. Before installing AZ/EL Cap onto ground pole, a concrete foundation should be in place and cured. "U" BRACKET HEX NUT, CARRIAGE BOLT (8) MODEL 611612001 (Fine Tune Option) Loosen (8) Carriage Bolts and nuts securing the “U” Bracket to the Top Bracket and “U” Bracket to (2) half clamps and swivel nut, hex nut (for optional fine tune feature).
ASSEMBLY AND INSTALLATION EARTH STATION ANTENNA AZIMUTH (IN DEGREES) FEED AND FEED LEG INSTALLATION 230 220 210 200 190 180 120 130 140 150 160 170 180 HEMISPHERE 240 110 NORTHERN 250 90 270 260 270 EAST WEST NOTE: Long formed end of Side Feed Leg attaches to the Reflector rim, short formed to side of Feed Support Terminal. 0 Assemble Bottom Feed Leg to bottom of Reflector rim. From the inside of Reflector rim, insert M6 x 16mm Hex Bolt thru hole in rim and attach Bottom Feed Leg.
ELEVATION CHART ASSEMBLY AND INSTALLATION " L" IS THE DIFFERENCE BETWEEN THE EARTH STATION ANTENNA SITE LONGITUDE AND THE SATELLITE LONGITUDE 1.2m System (Ref. Fig. 1.6) Attach Side Feed Legs and Braces to left and right sides of Reflector using M6 x 20mm Hex Bolts, Lock Washers and Hex Nuts. (NOTE: Long formed end of Feed Leg attaches to Reflector. Short formed end of Brace attaches to inside of Reflector rim.
ANTENNA ALIGNMENT PROCEDURE POLARIZATION CHART " L" IS THE DIFFERENCE BETWEEN THE EARTH STATION ANTENNA SITE LONGITUDE AND THE SATELLITE LONGITUDE NORTHERN HEMISPHERE POLARIZATION CHART SIGN VALUES (+ OR -) SOUTHERN HEMISPHERE 90 ANTENNA SITE WEST OF SATELLITE LONGITUDE ANTENNA SITE EAST OF SATELLITE LONGITUDE + Loosen Feed Horn Clamp Bolts and turn Feed clockwise or counterclockwise, depending on being east or west of the satellite as shown on Chart 1.
