Installation Guide

4
RIGHT HANDED - EXTERIOR VIEW
LEFT HANDED - EXTERIOR VIEW
3. HANG HINGED STORM DOOR
Tools needed:
In this step, you will place the door
in the opening and fasten it to the
mounting surface.
Set bottom of door into opening,
centering it in the opening.
Ensure orange bottom spacer is
sitting on door sill (Figure 9).
Tip the top of the door into the
opening while ensuring the
bottom of the door frame rests on
the orange spacer (Figure 9).
TIP: Place your foot against the
bottom of the door frame while
tipping the top of door frame
assembly into opening.
The door frame assembly is
properly seated in the opening
when both the latch rail and
hinge rail are fl ush against
the mounting surface and the
hinge z-bar and bottom spacer
(highlighted in yellow) are resting
on the door sill. (Figure 10)
NOTE: The gap between the top
of the door and the raincap is
intentionally uneven at this step.
The gap will become even in
later steps.
While holding door in position,
use the 1/8” drill bit (included in
the closer kit) to drill a hole in
the mounting surface through
pre-drilled holes marked “A” and
“B” in (Figure 10).
Fasten the door to the mounting
surface using two #8 x 1 screws,
included in closer kit. (Figure 10).
Pre-drill holes in the mounting
surface through the remaining
ten holes in the side rails.
Fasten the door to the mounting
surface using ten #8 x 1 screws.
Remove two handle hole
fasteners by inserting a Phillips
screwdriver into the handle hole
and fi rmly pressing them out.
(Figure 11) Properly discard
orange handle fasteners.
Graps the edge of the door and
fi rmly pull the door open.
NOTE: DO NOT OPEN DOOR
BY PULLING ON THE HANDLE
HOLES, INJURY COULD
RESULT.
Using the 1/8” drill bit, drill holes
in the door jamb through the
holes in the hinge rail.
Fasten the hinge rail to the door
jamb using eight #8 x 1 screws
(Figure 12). Do not overtighten
the screws.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
20 - #8x1”
1/8”
1/8”
Figure 9
Figure 10
A
B
Figure 9
B
A
Figure 10
Figure 11
Figure 12
Figure 11
Figure 12
1
1
1
1
1
1
1
8
1
8
4
4