Installation Guide

ManualsBrandsAMERISTAR ManualsMounting kitAMERISTAR MAYEXMK002A/003A Extreme Condition Curb Mounting Kit

88-MACC020-1A-EN

Extreme Condition Curb Mounting Kit

MAYEXMK002A/003A

Installer’s Guide

Used with 2 - 5 Ton Double Deck Gas Units Only

Safety Section

WARNING

▲

HAZARDOUS VOLTAGE!

Failure to follow this Warning could result in property

damage, severe personal injury, or death.

Disconnect all electric power, including remote

disconnects before servicing. Follow proper lockout/

tagout procedures to ensure the power cannot be

inadvertently energized.

WARNING

▲

Only qualified personnel should install and service the

equipment. The installation, starting up, and servicing

of heating, ventilating, and air-conditioning equipment

can be hazardous and requires specific knowledge

and training. Improperly installed, adjusted or altered

equipment by an unqualified person could result

in death or serious injury. When working on the

equipment, observe all precautions in the literature

and on the tags, stickers, and labels that are attached

to the equipment.

CAUTION

▲

SHARP EDGE HAZARD!

Failure to follow this Caution could result in personal

injury.

Be careful of sharp edges on equipment or any cuts

made on sheet metal while installing or servicing.

Personal injury may result.

ALL phases of this installation must comply with NATIONAL, STATE AND LOCAL CODES

IMPORTANT — This Document is customer property and is to remain with this unit. Please return to service information

pack upon completion of work.

General Data

Kit Contents

Open and inspect kit contents for damage or missing

items. Each kit contains:

Items Quantity

Hold-Down Bracket 8

Self-drilling #12-3/4 Screws 48

Inspection

Check carefully for any shipping damage. This must be

reported to and claims made against the transportation

company immediately. Any missing parts should be

reported to your supplier at once and replaced with

authorized parts only.

Summary of content (4 pages)

PAGE 1
88-MACC020-1A-EN Installer’s Guide Extreme Condition Curb Mounting Kit MAYEXMK002A/003A Used with 2 - 5 Ton Double Deck Gas Units Only ALL phases of this installation must comply with NATIONAL, STATE AND LOCAL CODES IMPORTANT — This Document is customer property and is to remain with this unit. Please return to service information pack upon completion of work. Safety Section ▲! WARNING Only qualified personnel should install and service the equipment.
PAGE 2
Installer's Guide Installation Instructions These instructions are organized for an easy step-by step procedure. 1. Prior to setting the packaged unit onto the curb, attach the eight (8) brackets to the curb flange. There will be three (3) brackets on each of the long sides of the unit and one (1) bracket on each of the short sides of the unit. Each bracket will require three (3) of the #12 x 3/4” self-drilling screws supplied in the kit and attach to the curb flange as shown in Figure 1. Figure 1.
PAGE 3
Installer's Guide 2. Place the packaged unit on top of the curb. Using three (3) additional #12x3/4” self-drilling screws per bracket, attach the brackets to the unit base rail. Figure 2. MAYEXMK002A Bracket Locations on ******24 - 42 Models NOTE: See Figure 2 for the location of brackets on ******24 - 42 models. Three (3) brackets on each of the long sides and one (1) bracket on each of the short sides. HOLD DOWN BRACKETS NOTE: See Figure 3 for the location of brackets on ******48 - 60 models.
PAGE 4
About Trane and American Standard Heating and Air Conditioning Trane and American Standard create comfortable, energy efficient indoor environments for residential applications. For more information, please visit www.trane.com or www.americanstandardair.com The manufacturer has a policy of continuous data improvement and it reserves the right to change design and specifications without notice. We are committed to using environmentally conscious print practices.