Technical Specifications
WARRANTY
10 (Ten) Year Non-Prorated Material Warranty Against Yellowing and 5 (Five) Year Non-Prorated Warranty
against breakage caused by hail for Coverlite Corrugated Solar Grade Polycarbonate Panels
AmeriLux International LLC warrants the initial purchaser that, for a period of 10 (ten) years from the date of original
purchase, Coverlite Solar Grade Polycarbonate Corrugated will not undergo a loss in light transmission in excess of 6
(six) percent in comparison with the original value when tested in accordance with ASTM D 1003 (95); will not
undergo a change in excess of 10 (ten) delta in comparison with the original value when tested in accordance with E
313-73 and will not lose its impact strength as described below.
Determination of loss of impact strength through weathering leading to hail breakage will be carried out by an impact
test according to ASTM D 5420-95 and D 5628-95 method F geometry FA (tip diameter 15.86 mm). In the practice of
this test the event is considered as a failure when the upper wall of the sheet is penetrated by the tip. The sheet is not
up to required standard if the Mean Failure Energy obtained in the test is less than 0.831 Joule. This energy is equal to
the energy of an ice ball 20 mm in diameter with a speed of 21 m per second.
IF COVERLITE CORRUGATED SOLAR GRADE SHEETS DO NOT PERFORM AS STATED DURING
THE WARRANTY PERIOD, AMERILUX INTERNATIONAL LLC SHALL SUPPLY REPLACEMENT
SHEETS OR, AT THE OPTION OF AMERILUX INTERNATIONAL LLC, REFUND THE PURCHASE
PRICE THEREOF.
AmeriLux International LLC shall have no liability whatsoever for the cost of removal of defective sheets or the
installation of replacement sheets and shall not be liable for any consequential or other loss, damage, misuses,
improper storage, neglect or misapplication of the product.
The warranties herein are made to the original purchaser, are personal to him, and shall not inure to the benefit of
subsequent purchasers, transferees, assignees, successors or receivers.
Conditions:
This warranty applies only to Coverlite Corrugated Solar Grade Polycarbonate Sheets which are treated, installed,
cleaned and maintained according to manufacturer’s recommendations. It is important to note that Coverlite Solar
Grade Polycarbonate Sheets are protected on one side with a special weathering Ultra-Violet (UV) radiation
prevention treatment. This protected side must be installed on the exterior side of the installation for this warranty to
be in effect. No warranties are extended on the abrasion resistance characteristics of this product. No warranties are
extended on the on the yellowing or loss of light transmission caused by dirt, scratches, breakage or other damage.
This warranty specifically excludes Coverlite Corrugated Solar Grade Polycarbonate Sheets that have been formed or
molded by vacuum or heat methods. This warranty applies only to Coverlite Corrugated Solar Grade Polycarbonate
Sheets..
AmeriLux International LLC., or its accredited agent must be notified in writing of every claim within the warranty
period and immediately after occurrence of the defect, enclosing the sales receipt and warranty. The claimant must
certify that the conditions above have been fulfilled and must allow inspection at the installation site.
THE FOREGOING IS THE SOLE AND EXCLUSIVE WARRANTY APPLICABLE TO COVERLITE
GRECA CORRUGATED SOLAR GRADE POLYCARBONATE SHEET. ANY OTHER CLAIMS FOR
DAMAGE OR LOSS EITHER DIRECT, INDIRECT OR CONSEQUENTIAL, WHATEVER THE CAUSE
THEREOF, ARE EXPRESSLY EXCLUDED FROM THE WARRANTY. AMERILUX TIONAL LLC
WARRANTIES, EXPRESSED OR IMPLIED, BUT NOT LIMITED TO, ANY IMPLIED WARRANTIES OF
MERCHANTABILITY FOR A PARTICULAR PURPOSE.