WALK-IN BATH INSTALLATION INSTRUCTIONS AND OWNER’S MANUAL
CONGRATULATIONS! You are now the owner of a walk-in bathtub from the most trusted name in plumbing. We thank you for your purchase. Your American Standard ® walk-in bath is a true investment in your health and peace of mind.
OWNERS MANUAL TABLE OF CONTENTS UNPACKING THE UNIT………………………………………………………………. Page 3 RESPONSIBILITIES OF THE INSTALLER…………………………………………… Page 4 TESTING YOUR TUB BEFORE INSTALLATION…………………………………… Page 5 INSTALLATION PREPARATION…………………………………………………….. Page 6 ELECTRICAL INSTALLATION………………………………………………………. Page 7 INSTALLATION PROCEDURES……………………………………………………... Page 8-9 SAFETY INSTRUCTIONS ……………………………………………………………. Page 10 OPERATING INSTRUCTIONS………………………………………………………..
OWNERS MANUAL UNPACKING THE UNIT 1. FIRST, inspect the carton for damage: Take a picture if possible. CAREFULLY RECORD ALL PERCEIVED DAMAGE and call us at 1-866-423-0800. 2. DO NOT LIFT THE TUB BY THE PLUMBING. Doing so can result in leaks, for which the installer is responsible. All Walk-In Tubs are water tested before they leave our factory and the bathtub you have purchased has passed inspection. 3. Immediately inspect the unit for damage even if there is no carton damage.
OWNERS MANUAL RESPONSIBILITIES OF THE INSTALLER The Installer must inspect and water test the product prior to installation to ensure the unit is free of defect and /or damage. In the event of a problem, the unit must not be installed. If the packaging or product has been damaged, please call immediately at 1-866-423-0800. This product has been listed by INTERTEK / ETL and IAPMO / C UPC. The product has been tested and complies with the following standards and guidelines: IAPMO /C UPC, UL-1795, ANSI Z-124.
OWNERS MANUAL TESTING YOUR WALK-IN TUB BEFORE INSTALLATION 1. All American Standard® walk-in baths are 100% water tested at the factory and have passed inspection. Transportation and mishandling may loosen fittings and cause leaks. It is therefore necessary to test the bathtub while there is access to all sides of the bath. 2. This unit should be both static and operationally tested with water. It is best to test the unit outside by filling with a garden hose. a.
OWNERS MANUAL INSTALLATION PREPARATION 1. Check the floor area where the tub is to be installed. a. Clean area of any debris or trash. b. Use a 5 or 6-foot level and determine if the floor is level. If the floor is not level, adjust all 5 leveling feet to perfectly level the tub. Note: It is important that all 5 leveling feet are completely touching the floor and level for the door system to work properly. 2. Check to ensure that the drain piping has been “roughed-in” at the proper location.
OWNERS MANUAL ELECTRICAL INSTALLATION All electrical wiring must be installed in accordance with the National Electrical Code and with all local codes. All wiring shall be done by a qualified electrician. Run one, two or three branch circuits (as required) from the main electrical service panel to the pump area of the framing structure to provide power to the unit. Electrical components have specific wiring requirements.
OWNERS MANUAL INSTALLATION PROCEDURES ▲ WARNING: When installing whirlpool massage baths, air spa baths, or combo baths, the following precautions must be followed: ▲ WARNING: Danger: Risk of electrical shock; connect components to separate circuits, EACH protected by a ground fault circuit interrupter (GFCI) ▲ WARNING: Installation must provide access for servicing the pump and motor (all American Standard® walk-in baths come with access panels for the pump, motor and faucet). 1.
OWNERS MANUAL Alcove Installation ` Faucet and Pump Access Panels IMPORTANT Do not use tile flange to screw or nail tub in place. Integral Flange Non Integral Flange Model A B C D E F G 2651.110 50.5” 26 ¼” 37 ½” 9 ½” 11 ½” 15 ½” N/A 2848.100 48” 28” 38” 10 ¾” 14” 16 ¾” N/A 3051.110 50.5” 30 ½” 37 ½” 9 ½” 14½” 15 ½” N/A 3260.
OWNERS MANUAL IMPORTANT SAFETY INSTRUCTIONS INSTRUCTIONS PERTAINING TO RISK OF FIRE, ELECTRICAL SHOCK OR INJURY TO PERSONS WHEN USING THIS UNIT, BASIC PRECAUTIONS SHOULD ALWAYS BE FOLLOWED. ▲ WARNING: Risk of personal injury. Use this unit for its intended use as described in this manual. DO NOT use attachments not recommended by the manufacturer. ▲ WARNING: Risk of personal injury. To avoid injury, exercise caution when entering or exiting your walk-in bath. ▲ WARNING: Risk of personal injury.
OWNERS MANUAL SAVE THESE INSTRUCTIONS! OPERATING INSTRUCTIONS 1. Enter the American Standard® walk-in bath, close the door, place handle in down position, and fill the bath to at least 2 inches above the highest jet before activating the pump. Do not put weight on the door when entering and exiting the tub. It is recommended to leave the door in the open position when the tub is not in use. 2. The pump is operated by the on/off switch. Both the number of buttons and their assorted functions vary.
OWNERS MANUAL created by this modification. Seek the help of a qualified professional. 10. DO NOT use bubble bath or Epsom salts when any pumps are operating. Bath oils may be used; however, their use will require more frequent purging and cleaning of the whirlpool and/or air spa systems. 11. Both whirlpool and air spa systems are designed so that water will drain from the plumbing after each use. 12. There are no user-serviceable parts located under the tub.
OWNERS MANUAL CLEANING AND MAINTENANCE Pump and pipe circulation systems should be flushed before first use and on a monthly basis when product is under normal use. Below are the recommended procedures for cleaning: • Do not run whirlpool dry. Fill the tub with hot water 2-3 inches above the jets and add 2-3 teaspoons of low foaming detergent such as dishwashing machine detergent. • Turn on whirlpool system and run for 10 minutes. • Drain tub completely. • Fill tub with cold water above jets.
OWNERS MANUAL LIMITED WARRANTY COVERAGE American Standard® Walk-In Baths are warranted in accordance with the following warranty: This warranty is extended to the first purchaser and does not extend to products previously used as display models or products that have been modified or repaired by anyone else but American Standard® unless approved by American Standard®. American Standard walk-in baths come with a ten year warranty on the bathtub, components and a lifetime warranty on the door seal.
