Installation guide

ManualsBrandsAmana ManualsFurnaceVR8205

*NOTE: Please contact your distributor or our

website for the applicable product data book

referred to in this manual.

2002-2004 Goodman Company, L.P.

Effective: May 2004

Part No. 10500226

Printed in U.S.A.

USER’S INFORMATION MANUAL

ACKAGE

-E

LECTRIC

F THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION

MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE.

–

O NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE

VICINITY OF THIS OR ANY OTHER APPLIANCE.

–

WHAT

YOU

SMELL

GAS

•

O NOT TRY TO LIGHT ANY APPLIANCE.

•

O NOT TOUCH ANY ELECTRICAL SWITCH; DO NOT USE ANY PHONE IN YOUR BUILDING.

•

MMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR’S PHONE.

OLLOW THE GAS

SUPPLIER’S INSTRUCTIONS.

•

F YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE DEPARTMENT.

–

NSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED INSTALLER, SERVICE AGENCY

OR THE GAS SUPPLIER.

WARNING

Installer - Affix this manual, Installation Guide, and Warranty adjacent to the

appliance.

Owner - Read and keep all product literature in a safe place for future

reference.

WARNING

HOULD OVERHEATING OCCUR, OR THE GAS SUPPLY FAIL TO SHUT OFF,

SHUT OFF THE MANUAL GAS VALVE TO THE FURNACE BEFORE SHUTTING OFF

THE ELECTRICAL SUPPLY.

WARNING

O AVOID PROPERTY DAMAGE, PERSONAL INJURY OR DEATH, DO NOT USE

THIS FURNACE IF ANY PART OF THE FURNACE HAS BEEN UNDER WATER.

MMEDIATELY CALL A QUALIFIED SERVICE TECHNICIAN TO INSPECT THE

FURNACE AND TO REPLACE ANY PART OF THE CONTROL SYSTEM AND ANY

GAS CONTROL HAVING BEEN UNDER WATER.

WARNING

RODUCT CONTAINS FIBERGLASS WOOL.

ISTURBING THE INSULATION IN

THIS PRODUCT DURING INSTALLATION, MAINTENANCE, OR REPAIR WILL

EXPOSE YOU TO FIBERGLASS WOOL.

REATHING THIS MAY CAUSE LUNG

CANCER. (

IBERGLASS WOOL IS KNOWN TO THE

TATE OF

ALIFORNIA TO

CAUSE CANCER.)

IBERGLASS WOOL MAY ALSO CAUSE RESPIRATORY, SKIN,

AND EYE IRRITATION.

O REDUCE EXPOSURE OR FOR FURTHER

INFORMATION, CONSULT MATERIAL SAFETY DATA SHEETS AVAILABLE FROM

ADDRESS SHOWN BELOW OR CONTACT YOUR SUPERVISOR.

is a trademark of Maytag Corporation and is used under license to

RECOGNIZE THIS SYMBOL AS A SAFETY PRECAUTION.

C E R T I F I E D

Summary of content (8 pages)

PAGE 1
PACKAGE GAS-ELECTRIC USER’S INFORMATION MANUAL DESIGN CE RT I F I E D CE RT IF IE D ® ® WARNING IF THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. – DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. – WHAT TO DO IF YOU SMELL GAS: • DO NOT TRY TO LIGHT ANY APPLIANCE.
PAGE 2
SIGNAL WORDS Dear Homeowner, please recognize the following safety information. This information will alert you to the potential for personal injury. Gutters or deflectors must be installed on the roof to prevent water from shedding on the unit. 1. An area must be available to reach the unit in a clear and unobstructed path. WARNING - Indicate hazards or unsafe practices which COULD 2.
PAGE 3
WARNING WARNING PERSONAL INJURY OR DEATH FROM ASPHYXIATION CAN RESULT FROM EXPOSURE TO CARBON MONOXIDE. CARBON MONOXIDE OR “CO” IS A TO AVOID PERSONAL INJURY OR FIRE, MINIMUM CLEARANCES TO COMBUSTIBLE SURFACES MUST BE FOLLOWED. COLORLESS AND ODORLESS GAS PRODUCED WHEN FUEL IS NOT BURNED AIR REQUIREMENTS COMPLETELY OR WHEN THE FLAME DOES NOT RECEIVE SUFFICIENT OXYGEN.
PAGE 4
WARNING AN UNDETECTED GAS LEAK WILL WARNING AN UNDETECTED GAS LEAK CAN CREATE A DANGER OF EXPLOSION THE UNIT AND ITS GAS CONNECTIONS MUST BE LEAK TESTED CREATE A DANGER OF EXPLOSION OR FIRE. OR FIRE. IF THE PRESENCE OF GAS IS SUSPECTED, FOLLOW THE INSTRUCTIONS ON THE COVER OF THIS MANUAL. FAILURE TO DO SO BEFORE PLACING IN OPERATION. COULD RESULT IN SERIOUS PERSONAL INJURY OR DEATH. HEATING START UP THERMOSTAT To put your unit into operation, follow the steps listed below.
PAGE 5
Gas Valve On/Off Selector Switch O F F INLET ON M 1 P 3 C 2 WARNING IF THE SECONDARY LIMIT CONTROL SHOULD OPEN, THE REASON MUST BE DETERMINED BEFORE THE CONTROL RESETS. THE ELECTRICAL POWER OUTLET MUST BE DISCONNECTED BEFORE ANY PANEL IS REMOVED OR MAINTENANCE IS PERFORMED.
PAGE 6
COMPRESSOR PROTECTION DEVICES ensure that adequate combustion air is being drawn and the vent system is working properly. Particular attention should be paid to the following items. Repair as necessary. This gas/electric package unit includes components which are designed to protect the compressor against abnormal operating conditions. • Check physical support of the unit. Ensure it is sound without any sagging, cracks, or gaps, around the base. • Check for obvious signs of deterioration of the unit.
PAGE 7
A return air filter is not supplied with this unit; however, there must be a means of filtering the return air. The filter(s) may be located in the return air duct(s). Consult with your installing dealer for the actual location of the return air filter(s) in your unit. FOR ADDITIONAL INFORMATION Most questions can be answered by your local dealer.
PAGE 8
Safety Labels WARNING: IMPROPER INTALLATION, ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CAN CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE, OR EXPOSURE TO SUBSTANCES IN FUEL OR FROM FUEL COMBUSTION WHICH CAN CAUSE DEATH OR SERIOUS INJURY, AND WHICH ARE KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS, OR OTHER REPRODUCTIVE HARM. REFER TO THE USER'S INFORMATION MANUAL PROVIDED WITH THIS FURNACE.