Operating instructions

Ga s Fr yer Op er a ti on & Ca re M an ua l • 77
A S F - 7 5 G S E R V I C E
LOC PART NO QUAN. UNIT DESCRIPTION
M
O-27011 1 EA MOTOR, LIFT(SIR) ASF-75G
PI-27539 2 EA PIN, 1/4” X 1-1/4”, CLEVIS
PI-27540 2 EA PIN, COTTER, ASF-75G,E
R
I-2097 2 EA RIVET, BLIND, #42, STLN/STLN
RD-27822 1 EA LIFT ROD
SC-25286 2 EA SCREW, 10-32X1/2, NF PHIL TRUSS
S
C-2661 4 EA SCREW, 10-32X1/2”, NF, PHIL TRUSS
SC-26790 2 EA SCREW, 10-32X32X1”, HEX HD, 18-8
24 5004456 1 EA CHIMNEY WELD ASB, ASF-75G
1005509 1 EA CHIMNEY A , ASF-75G
1005510 1 EA CHIMNEY B , ASF-75G
1005511 1 EA CHIMNEY C , ASF-75G
25 5004690 1 EA REAR CHIMNEY END SPOT, ASF-75G
1005857 1 EA CHIMNEY REAR END, ASF-75G
1005858 1 EA CHIMNEY REAR END 2, ASF-75G
1006260 1 EA BRACKET,REAR, CHIMNEY, ASF-75G
27 5005981 1 EA WLDMT - FLUE - SPOT ASSB
1006708 1 EA CAP, FLUE
1006709 1 EA COVER, FLUE
GS-27523 1 EA GASKET, FLUE, GAS FRYER
29 5005801 1 EA DOOR WELD & ASSB, ASF-75G
1007061 1 EA PLATE, DOOR MAGNET, MOUNT, ASF
1007063 1 EA DOOR OUTSIDE, ASF-75G
1007443 1 EA PANEL, INNER DOOR, FRYER
HG-26994 2 EA HINGE FOR ASF-75G, E
HG-27687 2 EA HINGE-MALE
PI-27689 2 EA PIN, HINGE
35 5004464 1 EA SOCKET & RING WELD, ASF-75G
FT-27254 1 EA COUPLING, 3/4 NPT.FULL S/S
WS-27247 1 EA WASHER, 1" DIA,INSIDE
37 1005547 1 EA SPLASH GUARD, FAT
38 5005054 1 EA THERMO BRK, SUB ASSB, ASF-75G
5005092 1 EA PANEL,THERMO BRK, SPOT, ASF-75G
CL-22259 12 EA CLIP, *CT,1.25 x 1, IOGA MILD
IN-22253 2 SF INSULATIONS, *CT,KIT, 20mm, FOIL
IN-24588 2 SF INSULATION,1"x 4' x25' #6, RT2300
39 5005051 1 EA PANEL, CONTROL, ASSB, ASF-75G
5004420 1 EA CONTROL PANEL SPOT, ASF-75G
FI-33406 2 EA FILTER, FERRITE, CABLE CLAMPS
IN-22985 1 SF INSULATION,1/2", CERAMIC WOOL
NU-2296 6 EA NUT, 8-32,NC HEX MS #18-8 S/S
PE-26571 1 EA PANEL, OVERLAY, DUAL CONTROL
PE-26572 2 EA PANEL, OVERLAY, INSERT CARD
SP-33901 8 EA SPACER, 5/8", CIRCUIT BRD MOUNT
WS-27045 6 EA WASHER, #8, LOCK WASHER, ASF-75G
40 5005135 1 EA CONTROL, MID, SUB ASB, ASF-75G
1005546 1 EA CONTROL PANEL, ASF-75G
1006303 1 EA BRACKET, MAGNET, DOOR MOUNT,ASF
LI-34251 1 EA PUSH BUTTON LENSE,RMQ TITAN,CONTACT
LOC PART NO QUAN. UNIT DESCRIPTION
L
I-34252 1 EA LIGHT, PUMP BUTTON, RMQTITAN, LED
LT-34280 1 EA LIGHT, ALARM, LED, RED BUTTON
LT-34281 1 EA LIGHT, ALARM, LED FOR ASF-75G
M
A-27568 1 EA MAGNET, SMCO
PA-27057 2 EA PLATE, RMQ TITAN, MOUNTING
PE-27761 1 EA PANEL, OVERLAY, LOWER, CONTROL
R
I-2097 2 EA RIVET, BLIND, #42, STLN/STLN
SC-22271 2 EA SCREWS,*CT,M4-0.7x6mm PHIL
SD-22194 4 EA SPRING,SAFETY,CT, M6X48mm,SAFETY
S
T-22193 4 EA STUDS, CT, M6x27mm, 1/4 TURN
SW-34240 1 EA SWITCH-BACK, PUSH BUTTON,FRYER,GAS
SW-34254 1 EA SWITCH, CAM, FOR SINGLE PHASE
TT-34245 1 EA THERMOSTAT, MAXIMUM, FRYER,ELEC.
WS-22195 4 EA WASHERS, CT, SAFETY, STEEL
41 5005053 1 EA BOARD, CIRCUIT, ASSB
1005833 1 EA BOX,MOUNTING, FRYER CONTRL, ASF
BA-34261 1 EA BOARD,RELAY, FRYER, GAS,ELEC
BA-34439 1 EA BOARD, CIRCUIT, POWER, ASF-75G,E
BA-34440 1 EA BOARD, CIRCUIT, SLAVE, ASF-75G,E
BP-3567 1 EA BEEPER, SOLID STATE, 1.5-20V
CB-34441 1 EA CABLE, BLACK, OVERLAY, ASF-75G,E
CR-33509 1 EA CONNECTOR, TERM, .25” F Q-SLIDE
NU-2361 2 EA NUT, 6-32, S/S, MS, HEX, 1/4” ACROSS
SC-2472 2 EA SCREW, 6-32 X 1/2, NC PHIL TRUSS
SC-33706 4 EA SCREW, 1/4"STANDOFF, HEX
SP-27079 4 EA SPACER, 1", CIRCUIT BOARD MOUNT
SP-33707 18 EA SPACER, SUPPORT, CIRCUIT BOARD
42 KN-34239 2 EA KNOB, PUMP
46 1006033 1 EA BACK ACCESS PANEL
53 5006236 1 EA ASSY. FAT DRAWER - ACTIVE FILTER
5006162 1 EA FILTER, CART, BOX ASSY.
CS-27054 2 EA CASTER,GREASE TRAY, SWIVEL
CS-27253 2 EA CASTER, GREASE TRAY, RIGID
HO-27649 1 EA HOSE, FRYER FILTER
PN-27701 1 EA PAN, WELDMENT, FAT DRAWER
SC-2661 16 EA SCREW, 10-32x1/2”,NF PHIL TRUS HD
NOT SHOWN FRYER ACCESSORIES
1006129 1 EA BRACKET, CHIMNEY, HOLDER
1007246 1 EA BRACKET, T-BLOCK
5005136 1 EA COVER, ASSB, FRYER, ASF-75G
BS-27140 2 EA BASKET, HALF SIZE, ASF-75E,G
BH-27121 1 EA BRUSHES, FRYER ACCESSORIES, 24”
BH-27382 1 EA BRUSH, CLEAN OUT TOOL, ASF-75G
CE-27122 1 EA CLEANER, SCRAPER, FRYER
CE-27400 1 EA CLEANER,SRAINER,SKIMMER,GAS,EL
FI-27014 1 EA FILTER, FRYER, GAS, ELEC
FI-27015 1 EA FILTERHOLDER, FRYER, GAS, ELEC
VA-27321 1 EA VALVE, 3/4 NPT BALL, FULL PORT
PB-27264 1 EA KIT,UNIVERSAL GAS HOOK UP