Service manual

170 800170
Section 5 Service Procedures
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
To reduce the risk of electric shock, fire, explosion, serious injury or death:
• Disconnect electric power to the washer/dryer before servicing.
• Close gas shut-off valve to gas dryer before servicing.
• Never start the washer/dryer with any guards/panels removed.
• Whenever ground wires are removed during servicing, these ground wires must be
reconnected to ensure that the washer/dryer is properly grounded.
W014R1
WARNING
98. WASHER DOOR SWITCH
a. Open loading door.
b. Carefully remove wire clamp ring from groove
with small flat screwdriver. Spring is located in
the 6 o’clock position. Refer to Figure 28.
c. Grasp door seal and slide seal away from top
half of the door opening. Refer to Figure 28.
d. Reach up between door seal and front panel.
Refer to Figure 31. Press in on switch locking
tabs and push switch out through front panel
only far enough to allow removal of wires from
switch terminals.
IMPORTANT: Refer to wiring diagram when
rewiring switch.
99. WASHER DOOR LATCH SWITCH
a. Open loading door.
b. Carefully remove wire clamp ring from groove
with small flat blade screwdriver. Spring is
located in the 6 o’clock position. Refer to
Figure 28.
c. Grasp loading door seal. Refer to Figure 21.
d. Using a circular motiion, pull seal up, out and
down. Refer to Figure 21.
e. When seal releases from lip of front panel, pull
out and remove the seal.
f. While supporting door lock from behind
(through door opening), remove two Phillips
head screws holding door latch switch to front
panel. Refer to Figure 31.
g. Gently pull door lock out through door opening.
Remove door lock only far enough to
disconnect harness connector from door lock.
Refer to Figure 31.
NOTE: When installing new door lock, be sure to
install small lip through mounting hole first and
then rotate lock into position.
Figure 31
B
L
E
A
C
H
S
O
F
T
E
N
E
R
M
A
X
M
A
X
C
o
m
m
e
r
c
i
a
l
W
a
s
h
e
r
/
D
r
y
e
r
WASHER
DRYER
H170SE3A
Door
Switch
Door
Latch
Switch
Door Latch
Switch
Attaching
Screws
Door
Switch
Wires
Wire
Harness