ALFRESCO™ Gourmet Grills A division of Superior Equipment Solutions, Inc. 1085 Bixby Drive City of Industry, CA. 91745 Ph.: (888) 383-8800 Fax: (323) 726-4700 Web: www.alfrescogrills.com 3020914 GENERAL SAFETY PRECAUTIONS: ! DANGER IF YOU SMELL GAS: 1. 2. 3. 4. SHUT OFF GAS TO THE APPLIANCE EXTINGUISH ANY OPEN FLAME. OPEN LID. IF ODOR CONTINUES, KEEP AWAY FROM THE APPLIANCE AND IMMEDIATELY CALL YOUR GAS SUPPLIER AND OR FIRE DEPARTMENT. ! DANGER S’IL Y A UNE ODEUR DE GAZ: 1. 2. 3. 4.
F AVERTISSEMENT PIÈCES ÉLECTRIQUES ET COMPOSANTS. DÉBRANCHER TOUS LES BLOCS D'ALIMENTATION ET LES PILES AVANT DE LES RÉPARER. H AVERTISSEMENT GAZ INFLAMMABLE DÉBRANCHER TOUS LES GAZ PROPANE OU GAZ NATUREL DE CET APPAREIL AVANT DE PROCÉDER À L'ENTRETIEN. TESTED IN ACCORDANCE WITH: ANSI Z21.58-2018 / CSA 1.6-2018 The Standard for Outdoor Cooking Gas Appliances. Installation of this cooking appliance must be made in accordace with local codes.
READ THIS CARE AND USE MANUAL CAREFULLY AND COMPLETELY BEFORE USING YOUR SIDE BURNER TO REDUCE THE RISK OF FIRE, BURN HAZARD OR OTHER INJURY. KEEP THIS MANUAL FOR FUTURE REFERENCE. When properly cared for, your ALFRESCO™ Side Burner will give safe, reliable service for many years. However, extreme care must be used since the Side Burner produces intense heat, which can increase accident potential.
For proper lighting and performance of the burners keep the ports clean. It is necessary to clean them periodically for optimum performance. The burners will only operate in one position and must mounted correctly for safe operation. Clean the Side Burner with caution. Avoid steam burns; do not use a wet sponge or cloth to clean the Side Burner while it is hot. Some cleaners produce noxious fumes or can ignite when applied to a hot surface.
LOCATING AND ASSEMBLING THE SIDE BURNER: When determining a suitable location for your Side Burner, take into account concerns such as exposure to wind, rain, sprinklers, proximity to traffic paths and keeping any gas supply line runs as short as possible. Locate the Side Burner only in a well-ventilated area. Never locate the Side Burner in a building, garage, breezeway, shed or other such enclosed areas without an approved ventilation system.
CART MODELS: Please follow the instructions supplied with the unit in order to mount and connect all required piping that comes with the unit. WARNING: To prevent harm and ensure proper operation of your Side Burner, it is imperative that the burners are properly installed with respect to the gas orifices. Be certain that the exterior cap and well as internal cap is inserted completely into the burner’s venture funnel and that the burner rests firmly on its supports.
LP GAS CONNECTION TO LP TANKS: Your ALFRESCO™ Side Burner for use with LP gas comes equipped with its own regulator, which MUST NOT be removed. There is also a secondary high capacity, hose/regulator assembly for connection to a standard 20 Lb. LP cylinder. The LP gas pressure regulator and hose supplied with this unit must be used without alteration. If this assembly needs to be replaced use only the type specified by ALFRESCO™ for this appliance.
! CAUTION ! WARNING CYLINDERS MUST BE STORED OUTDOORS IN A WELL VENTILATED AREA OUT OF THE REACH OF CHILDREN. YOUR ALFRESCO™ SIDE BURNER PRESSURE REGULATOR HAS A MAXIMUM INPUT PRESSURE OF 14” WC. (OR APPROX. .5 PSI) , AND A SAFETY LIMIT OF 69” WC. (2.5 PSI). DISCONNECTED LP CYLINDERS MUST HAVE THREADED VALVE PLUGS TIGHTLY INSTALLED, AND MUST NOT BE STORED IN A BUILDING, GARAGE OR ANY OTHER ENCLOSED AREA. THE GAS MUST BE TURNED OFF AT THE SUPPLY CYLINDER WHEN THE UNIT IS NOT IN USE.
If this regulator needs to be replaced use only the type specified by ALFRESCO™ for this appliance. To connect the piping or hose assembly follow the next steps: Locate the regulator and gas connection point in the rear side of your Side Burner. Verify that the a 1/2” FPT x 1/2” MPT (male-to-female) 90° Elbow connected to the regulator points in the required direction. (see Figure # 3) Fasten the pipe or hose connection to a 1/2” MFT elbow with the appropriate gas fittings.
BEFORE TESTING: Make sure that all packing material is removed from the Side Burner. Make sure the burner tie-down straps are removed from the unit. Do not smoke while leak testing. Never leak test with an open flame. Make a soap solution of one part liquid detergent and one part water for leak testing purposes. Apply the solution to the gas fittings by using a spray bottle, or brush. For LP units, always check with a full cylinder.
WARNING LIGHTING INSTRUCTIONS: THE COVER MUST BE REMOVED WHEN LIGHTING. BEFORE LIGHTING… The pressure regulator and hose assembly supplied with the unit must be used. Never substitute regulators for those supplied with the Side Burner. If a replacement is necessary, contact the factory for proper replacement. THE COVER SHOULD NOT BE CLOSED WHEN THE BURNERS ARE IN USE. Screw the regulator (Type QCC1) into the LP tank.
! WARNING NEVER ADJUST THE BURNER SO LOW THAT IT MAY GO OUT DURING USE. DO NOT OPERATE THE GRILL WITH THE LOW HEAT SCREW REMOVED. GAS CAN ESCAPE AND CAUSE A POTENTIALLY HAZARDOUS CONDITION. ! AVERTISSEMENT NE JAMAIS AJUSTER LE BRÛLEUR SI BAS QU'IL PEUT S'ÉTEINDRE PENDANT L'UTILISATION. N'UTILISEZ PAS LE GRIL AVEC LA VIS À CHALEUR BASSE RETIRÉE. LE GAZ PEUT S'ÉCHAPPER ET PROVOQUER UNE CONDITION POTENTIELLEMENT DANGEREUSE.
3. For really stubborn dirt or burnt-on grease, a nylon-scouring pad may be used in conjunction with the cream cleanser. On no account should “wire wool” pads be used unless they are made of stainless steel. 4. Harsh abrasives and scouring materials should not be used for cleaning stainless steel as they will leave scratch marks in the surface and damage the appearance of the Side Burner. Likewise do not use wire brushes, scrapers or contaminated scouring pads. 5.
TROUBLESHOOTING: BEFORE CALLING FOR SERVICE: If your ALFRESCO™ Side Burner does not function properly use the following checklist before contacting your dealer for service. You may save the cost of a service call and the inconvenience of being without your Side Burner. Additional troubleshooting tips can be found on our website at: www.alfrescogrills.com.
ADDITIONAL IMPORTANT CLEANING AND STORAGE CONSIDERATIONS: In order to maintain your Side Burner in clean working order, it will be necessary, under certain conditions, to take additional precautions. If your Side Burner is located in a coastal area, it will be exposed to salty air which is corrosive.
HOW TO OBTAIN SERVICE For service, please contact our Alfresco™ Gourmet Grills authorized service agency at: Please provide: (866) 203-5607 Model Number Serial Number (located under the drip pan) Gas Type Date of installation A brief description of the problem. For all other Alfresco™ Gourmet Grill product inquiries please contact: Alfresco Gourmet Grills. Customer Service Department. 1085 Bixby Drive City of Industry, CA. 91745 (888) 383-8800 or (323) 722-7900 (323) 726-4700.
Alfresco Limited Warranty (Residential use only) SIDE BURNERS LIMITED LIFETIME WARRANTY Alfresco will repair or replace any stainless steel part including all fabricated stainless steel components, standard round grates (excluding what is covered in the Five Year Limited Warranty) to be defective from workmanship and when subjected to normal residential use and service.
