Instruction manual

!""#$%&'()*+$,()*(-$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$$./0&1$21-3(4*4+$,5-3(6-
Starting & stopping the engine...
9. Apply the brake
on the Castor
Wheel to avoid
unexpected
movement of the
Powerig during
operation.
Push down with
foot to operate
brake.
Starting...
10. Set the throttle
at 50% maximum speed.
11. Turn the key clockwise
to position 1 as shown
below. The warning light
should illuminate.
12. Continue to turn the
key clockwise to position
2 to operate the electric
starter motor. Release
the key once the engine
has started. The key will
now return to position 1
and should be left in this position whilst the
engine is running.
CAUTION
Do not operate the starter for more than
20 seconds at a time. If the engine does
not start, wait 1 minute before trying
again.
If the engine does not start after two
attempts, trace the cause according to
the Diagnosis Chart (page 75 - 77) of the
Diesel Engine Maintenance Manual.
All warning lights should stay off when
the engine is running.
Note:
If there is not enough battery power to
operate the electric starter motor, the engine
maybe started with the recoil starter. Refer
to page 53 of the Diesel Engine
Maintenance Manual for instructions.
13. Move throttle lever to the idle position
and allow engine to run at idle for a few
minutes before increasing speed and
putting under load.
Note:
During the first 50 hours of running the
engine, do not exceed 70% of maximum
load.
Stopping...
14. Move throttle lever to the idle position
and allow engine to run at idle for a few
minutes.
15. Move the stop lever
fully to the left until the
engine stops.
16. Rotate the key anti-
clockwise to the stop
position.
Throttle Lever
Throttle Lever
Lock