SPORTSTER SE User’s Manual AFI KIM ELECTRIC VEHICLES KIBBUTZ AFIKIM 15148, ISRAEL TEL: 972-4-6754814, FAX: 972-4-6751456 e-mail: mainbox@afiscooters.com websites: www.afiscooters.
WARNING Read the User’s Manual carefully before operating the SPORTSTER. If you do not fully understand any part of this Manual, please contact your dealer or any of our Service Centers - as injury or damage may occur from misuse! WARNING Electromagnetic Interference (“EMI”) can cause powered vehicles to behave erratically, which could be dangerous to the user. For your safety and protection, it is IMPERATIVE that you take time to read Chapter 6 (“EMI WARNING”) before operating the SPORTSTER.
CE CERTIFICATION The Afikim Electric Vehicles Ref. Registration Number with the Competent Authority (UK) is: CA 000292. Our Authorized Representative with the Competent Authorities is: MEDES LTD.
CONTENTS CHAPTER 1 - Overview Of The Sportster SE ......................1 Safety Instructions .................................................................2 General Description Of The Sportster SE..............................3 CHAPTER 2 - Adjustment & Operating Instructions.............6 CHAPTER 3 - Maintenance................................................12 CHAPTER 4 - Charging......................................................15 CHAPTER 5 - Troubleshooting and Fault Repair ...............
CHAPTER 1 - OVERVIEW OF THE SPORTSTER SE Main features: Congratulations on choosing the SPORTSTER as your electrically powered vehicle. The SPORTSTER is easy to operate. The relatively large wheels enable driving on unpaved roads, over rough terrain and to overcome obstacles as high as 4” (10 cm). The SPORTSTER can climb slopes up to 21% - Single, 18% - Double. The braking system stops the SPORTSTER smoothly and a short distance after the Operating Lever is released.
SAFETY INSTRUCTIONS 1. Please note and strictly adhere to the following Safety Instructions. Additional Warnings and Notices are printed in this User’s Manual; it is imperative that you read carefully all chapters of this Manual before operating the SPORTSTER. It is also advisable to refresh your memory by re-reading this Manual periodically. Use gel/dry batteries only. 2. Get acquainted with the SPORTSTER and its operational features before driving it. 3.
GENERAL DESCRIPTION OF THE SPORTSTER SE Note: 1. The numbers in parentheses refer to the parts illustrated on Figure 1. Handlebars (2) There are two separate and independently adjustable handlebars, one of which houses the controls for the SPORTSTER. Your SPORTSTER is delivered to you with right-hand controls. (Lefthands controls can be ordered through your dealer). NOTE : On the Double Seat model the left handlebar is shorter to allow for easier steering by the driver with 2 people on board.
Single Seat Model Figure 1 4
TECHNICAL SPECIFICATIONS MODEL No. : Dimensions * Weights * Speed ** 5 Climbing ability Tires (pneumatic) Towing Batteries *** Travel distance Units Length (without rear basket) (with rear basket) Width Height (for transport: handles, seat and front wheel removed) Ground clearance Total, without batteries Total, with batteries Maximum load (including rear basket load) Forward (Speed selector position No. 2) Forward (Speed selector position No.
CHAPTER 2 - ADJUSTMENT & OPERATING INSTRUCTIONS (Reference numbers refer to the figures at the bottom of each page) Adjusting the Handlebars Adjust angles and height of both handlebars as follows: • Release the Handlebars Clamp (1), which secures the handlebars in place, by turning the cam Lever outward from the vehicle. • Adjust the height and angle of your handlebars, by turning, while raising or lowering the handlebars.
Key Switch • The SPORTSTER has a Main Key Switch (9) - located on the right side of the Headlight Housing. The Main Key Switch has two positions: • “OFF” - The SPORTSTER cannot be driven and the Electromagnetic Brake is locked. • “ON” - Power is supplied to the SPORTSTER. The Electromagnetic Brake releases automatically when the Operating Lever is squeezed. To operate the SPORTSTER, insert the key into the Main Key Switch and turn it to “ON” (clockwise).
Battery Status Indicator The Battery Status Indicator (1) located on top of the Headlight Housing shows you the remaining capacity of the batteries. When the indicator shows that mid-half capacity remains, recharge batteries as soon as possible. When the indicator points that to firs or second segment on the left there are only about 5 km (3 miles) to go. Fault Indicator When the green light of the Fault indicator (2) is lit, the vehicle is “ready”.
Speed Range Selector The Speed Range Selector (16) is located on the left side of the Headlight Housing. It has two positions: • Mark “1” (lower position): Low speed - up to 6 km/h (3.1 mph). • Mark “2” (upper position): High speed - 10 km/h (6.2 mph). Do not shift the selector while the SPORTSTER is in motion. Note: When driving the SPORTSTER inside a building or in a crowded area, use only position 1 (Low speed).
Horn/Buzzer (in certain models only) Push Button (20) activates a buzzer. The buzzer sounds automatically under the following conditions (subject to change where prohibited by law): 1. When reversing. 2. When operating the “Turn Signal Switch” (Right or Left). 3. When the “Emergency Electromagnetic Brake Lever ” is operated. Headlight Switch Turn on the Headlight (24) with Light Switch (23). This switch activates both the Headlight and the Rear Lights (28).
Parking After stopping, turn the Main Key Switch to OFF and remove the key. The lights will turn OFF. The Electromagnetic Brake is engaged (locked). Note: The Electromagnetic Brake is automatically locked whenever the Operating Lever is released and after the SPORTSTER stops completely. The Hand Brake Lever (26) can be locked by pushing Button (27) while squeezing Hand Brake Lever . To release the Hand Brake - squeeze Lever (26) gently.
CHAPTER 3 - MAINTENANCE Note: The numbers in parentheses refer to the parts illustrated in figure 2. Although the SPORTSTER requires minimal maintenance, do not neglect it. When servicing the SPORTSTER, make sure that it stands on a level surface and that the key is not inserted. In addition, lock the Hand Brake. Periodic Maintenance Check No. Type of Service Frequency 1 Check water level in the batteries. Add water as needed.
Single Seat Model Double Seat Model Figure 2.
Removing the Gray Cover (33) (Double Seat Model) Release the lock spring (37) under the Seat and tilt Seat (36) back about 70 degrees until it is almost standing on the rear part of the frame. Remove the Gray Cover (33) as described above (for Single Seat Model). Replacing the Gray Cover (33) (Double Seat Model) Replacement of the Gray Cover is done in reverse order. Tilt Seat back and mount on Seat Shaft. Batteries Every two months, check the water level in both batteries.
CHAPTER 4 - CHARGING Read Charger’s manual before using the charger.. Warning: If you use a different charger, ask your dealer for instructions. CHARGING BATTERIES (See figure 3) 1. Insert the Charging Plug into the Charging Socket located on the front of the GRAY COVER, at the center. 2. Plug the power cord of the charger into a wall outlet. 3. When charging is completed and you are ready to go - unplug the charger from the wall outlet and remove the charger plug from the SPORTSTER. 4.
Figure 3.
CHAPTER 5 - TROUBLESHOOTING AND FAULT REPAIR The following table provides troubleshooting and repair instructions for symptoms encountered when operating the SPORTSTER. It presents the best ways to handle the faults. The table contains three columns: The Symptom - describes the functional problem that results from the fault. Probable Cause - lists all probable causes for the relevant symptom. The probable causes are listed logically by order of probability: the first one is the most probable.
No. Symptom 6 SPORTSTER does not move when squeezing the Operating Lever . Probable Causes • Main Key Switch is in OFF position. • Charging Plug is installed in Charging Socket. • The Mechanical Release Lever of the Electromagnetic Brake is pushed Forward. • Control system failure. 7 8 9 Intermittent drive. RIGHT or LEFT turn signal light is inoperative. Headlight and/or rear light are not lit. Remedy ◊ Turn the key to “ON” position. ◊ Disconnect the Charging Plug from the SPORTSTER.
CHAPTER 6 - EMI WARNING All types of electrically powered vehicles, such as powered wheelchairs and motorized scooters (in this text all types will be referred to as “powered vehicles”) may be susceptible to electromagnetic interference (EMI). This is interfering electromagnetic energy (EM) emitted from sources such as radio and TV stations, amateur radio (HAM) transmitters, two-way radios and cellular phones.
WARNINGS Electromagnetic interference (EMI) from sources such as radio and TV stations, amateur radio (HAM) transmitters, two-way radios and cellular phones can affect powered vehicles.
Distributed by AFIKIM ELECTRIC VEHICLES KIBBUTZ AFIKIM, 15148, ISRAEL, Telephones Main Office: Sales Department: 972 4 6754814 972 4 6754180 Fax 972 4 6751456 E - Mail mainbox@afiscooters.com Websites www.afiscooters.
