Instruction Manual

AM Series Cascade Sequencer
INSTALLATION AND OPERATION MANUAL
TABLE OF CONTENTS
INTRODUCTION .................................................................................................................. 4
CHAPTER 1: INSTALLATION ........................................................................................... 5
1.1 PIPING INSTALLATION .................................................................................................................... 5
1.2 ELECTRICAL INSTALLATION ........................................................................................................... 6
1.3 MANAGER HEATER PREPARATION ............................................................................................... 8
1.3.1 Manager Heater Preparation - Communications Board ................................................................................... 8
1.3.2 Manager Heater Prep - S4 Switch on Communications Board ....................................................................... 12
1.3.3 Manager Heater Preparation - S4 Switch on the Burner #1 Board................................................................. 13
1.4 PREPARING THE CASCADE SEQUENCER FOR USE .................................................................. 14
1.5 SETTING THE LOGIC ADDRESS FOR EACH HEATER ................................................................. 15
1.6 SETTING FOR USE WITH BOILERS OR WATER HEATERS ......................................................... 17
1.7 DEPENDENT HEATER PREPARATION – SETTING PARAMETER 2003 ....................................... 17
1.7.1 AM Series Controller - Installer Menu Navigation .......................................................................................... 18
1.8 REVIEW OF ALL PARAMETERS .................................................................................................... 19
CHAPTER 2: OPERATION .............................................................................................. 20
2.1 CASCADE SEQUENCER DISPLAY AND CONTROLS .................................................................... 20
2.2 CASCADE STATUS BUTTON ......................................................................................................... 21
2.3 SUBMENU NAVIGATION, AND PARAMETER SETTINGS .............................................................. 21
2.4 SUBMENU PARAMETER LIST........................................................................................................ 23
2.5 MENU PARAMETER DESCRIPTIONS ............................................................................................ 22
2.6 TROUBLESHOOTING GUIDE ......................................................................................................... 24
OMM-0101_0A AERCO International, Inc. • 100 Oritani Dr. • Blauvelt, NY 10913 Page 3 of 26
GF-146-CS Ph.: 800-526-0288 PRI - 11/25/14