NE-C30-IM-FINAL 10/20/06 2:27 PM Page 1 INSTRUCTION MANUAL Compact Compressor Nebulizer MODEL NE-C30 Caution: Federal (USA) law restricts this device to sale by or on the order of a physician or licensed healthcare practitioner ENGLISH ESPAÑOL PORTUGUÊS 5 3
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 1 CONTENTS Before Using the Device Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 Safety Information Operating the Device . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Risk of Electrical Shock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Maintenance and Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 2 Before Using the Unit INTRODUCTION Thank you for purchasing the OMRON® NE-C30 Compact Compressor Nebulizer. Fill in for future reference. DATE PURCHASED: __________________ SERIAL NUMBER: ____________________ Staple your purchase receipt here This product was developed for the successful treatment of asthma, allergies and other respiratory disorders. The compressor forces air to the nebulizer.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 3 SAFETY INFORMATION To assure the correct use of the product basic safety measures should always be followed including the warnings and cautions listed in this instruction manual. SAFETY SYMBOLS USED IN THIS INSTRUCTION MANUAL WARNING Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 4 IMPORTANT SAFETY NOTES OPERATING THE DEVICE (continued) Do not insert any object into the compressor. Make sure the air filter is clean. If the air filter has changed color or has not been used for 60 days, replace the filter. Make sure the nebulizer kit is correctly assembled, the air filter is properly installed, and the air tube is correctly connected to the compressor and the nebulizer kit. Air may leak from the air tube during use if not securely connected.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 5 IMPORTANT SAFETY NOTES RISK OF ELECTRICAL SHOCK Do not connect the battery connector located on the bottom of the main unit to the rechargeable battery terminal using wire or other metallic conductors. Do not use the compressor (main unit), AC adapter, rechargeable battery or battery charger while they are wet. Do not plug or unplug the power cord into the electrical outlet with wet hands. Do not immerse the compressor (main unit) in water or other liquid.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 6 IMPORTANT SAFETY NOTES MAINTENANCE AND STORAGE Keep the device out of the reach of unsupervised infants and children. The device may contain small parts that can be swallowed. Do not leave the cleaning solution in the nebulizer parts. Rinse the nebulizer parts with clean hot tap water after disinfecting. Wash the nebulizer parts after each use. Dry the parts immediately after washing. Do not store the air tube with moisture or medication remaining in the air tube.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 7 KNOW YOUR UNIT Main Unit: Compressor Back View Front View Nebulizing Kit Power Indicator Power Switch Charge Indicator 5 3 Air Plug Power Connector Nebulizer Kit Holder Air Filter Cover Bottom View (*Air Filter Inside) Air Connector Air Plug Air Tube Battery Connector Components: Nebulizer Kit Cap Mouthpiece Child Mask Inhalation Air Inlet Inhalation Top Baffle AC Adapter Power Plug Medication Cup Nozzle Power Cord 5 3 Air Tube Connector 8
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 8 KNOW YOUR UNIT Components: Air Tube with attached Air Plugs Air Filters Package of 5 Air Filter Cover User Registration Card Carrying Bag Instruction Manual INSTRUCTION MANUAL Compact Compressor Nebulizer Instructional DVD MODEL NE-C30 Caution: Federal (USA) law restricts this device to sale by or on the order of a physician or licensed healthcare practitioner ENGLISH ESPAÑOL PORTUGUÊS 5 3 Optional Accessories: Adult Mask Nosepiece Rechargeable Batt
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 9 Operating Instructions PREPARING THE NEBULIZER FOR USE WARNING Clean and disinfect the nebulizer kit, mouthpiece, and optional nosepiece or masks before using them for the first time after purchase. WARNING If the device has not been used for a long period of time clean and disinfect the nebulizer kit, mouthpiece, and optional nosepiece or masks before using them. For directions on cleaning and disinfecting refer to page 17 and page 18.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 10 PREPARING THE NEBULIZER FOR USE 4. Lift up the baffle and remove the baffle from the medication cup. CAUTION Do not alter the baffle, the nozzle in the medication cup or any part of the nebulizer kit. 5. Add the correct amount of prescribed medication to the medication cup. WARNING max 5 3 Pentamidine is not an approved medication for use with this device.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 11 PREPARING THE NEBULIZER FOR USE 8. Attach the desired inhalation accessory. NOTE: Mouthpiece and Nosepiece Place the cap on the medication cup when using the mouthpiece or nosepiece. Using the cap with the mouthpiece or the nosepiece will reduce the amount of medication that is discharged into the air. B USING THE MOUTHPIECE Place the cap on the medication cup over the inhalation air inlet (A). Attach the mouthpiece (B).
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 12 ATTACHING THE AIR TUBE 1. Push the Air Plug on one end of the Air Tube onto the Air Connector on the front side of the compressor (A). 2. Push the Air Plug on the other end of the Air Tube onto the Air Tube Connector on the bottom of the Nebulizer Kit (B). NOTE: Keep the nebulizer kit upright when attaching the air tube. Medication may spill out of the medication cup.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 13 USING THE DEVICE WARNING Do not use the device where the device may be exposed to flammable gas or vapors. WARNING Do not use or store the device in humid locations, such as a bathroom. Use the device within the operating temperature and humidity. CAUTION Provide close supervision when this device is used by, on, or near infants, children or compromised individuals. CAUTION Do not use a cellular phone near the device. It may result in an operational failure.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 14 USING THE DEVICE Press the power switch again to stop nebulization. NOTE: The green light goes off. WARNING Do not cover the compressor with a blanket, towel, or any other type of cover during use. This could result in the compressor overheating or malfunctioning. CAUTION Do not block the air filter cover. 3. Inhale medication as instructed by your physician or licensed healthcare practitioner. USING THE MOUTHPIECE Insert the mouthpiece into your mouth.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 15 USING THE DEVICE 5. Press the power switch. The compressor turns off and nebulization stops. Power Indicator 6. Disconnect the Air Tube from the Nebulizer Kit. Hold the Air Plug and gently pull down to disconnect the Air Plug from the Air Tube Connector on the bottom of the nebulizer kit. 7. Check the Air Tube. No condensation or moisture should remain in the Air Tube. WARNING Do not store the air tube with moisture or medication remaining in the air tube.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 16 Care and Maintenance CLEANING AFTER EACH USE Following the cleaning instructions after each use will prevent any remaining medication in the bottle from drying resulting in the device not nebulizing effectively and will help prevent infections. WARNING Wash the nebulizer parts after each use. Dry the parts immediately after washing. 1. Remove the inhalation accessory (mouthpiece, mask, or nosepiece) from the nebulizer kit. 2.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 17 DAILY DISINFECTING You can disinfect daily by soaking the parts in a vinegar solution or using a commercially available medical disinfectant. If your physician or respiratory therapist specifies a different cleaning procedure follow their instructions. Disinfect the nebulizer kit and the mask, nosepiece or mouthpiece after the last treatment of the day. VINEGAR METHOD 1. Make a solution of 1 part white vinegar and 3 parts distilled water.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 18 DAILY DISINFECTING 7. Submerge the parts in the white vinegar and distilled water solution for 30 minutes. 8. Remove the parts and discard the solution. Rinse the parts with hot tap water. 9. Hand dry or air dry in a clean environment using a soft, clean, lint-free cloth. 10. Assemble the nebulizer and store the nebulizer kit in a dry, sealed bag. WARNING Store the device and the components in a clean, safe location.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 19 CHANGING THE AIR FILTER Change the air filter every 60 days even if the air filter does not appear dirty. If the air filter appears dirty, or if water or medication has spilled on the air filter, replace with a new air filter immediately. 1. Pull the air filter cover to remove from the front side of the compressor. 2. Remove the dirty filter with a small pointed object. CAUTION Do not attempt to wash or clean the air filter. Damp air filters can cause blockages.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 20 CARING FOR THE DEVICE To keep your device in the best condition and protect the unit from damage follow these directions: CAUTION Do not subject the compressor, rechargeable battery, battery charger or any of the components to strong shocks, such as dropping on the floor. CAUTION Use only Omron authorized parts and accessories. Parts and accessories not approved for use with the device may damage the unit.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 21 CARING FOR THE DEVICE STORING THE DEVICE 1. Put the nebulizer kit and the inhalation accessory (mouthpiece, nosepiece or mask) in a dry, sealed bag. Place the bag in the storage pocket of the carrying bag. 2. Coil the air tubing and place in the storage pocket. 3. Place the compressor in the carrying bag. CAUTION Do not wrap the power cord around the compressor (main unit). 4. Zipper the bag closed. 5. Store the device in a safe, clean location.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 22 TROUBLESHOOTING GUIDE PROBLEM No power on unit when the power switch is on. No nebulization or low nebulization rate when the power is on. CAUSE SOLUTION The AC power cord is not plugged into an electrical outlet. The rechargeable battery is not connected correctly, not sufficiently charged, or the battery has expired. Turn the power switch off. Plug the power plug into an electrical outlet. Turn the device on.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 23 WARRANTY LIMITED WARRANTIES Your Omron NE-C30 CompAir® Elite Nebulizer Compressor, excluding the nebulizer kit, inhalation accessories, air tube and air filters, is warranted to be free from defects in materials and workmanship appearing within 5 years from the date of purchase, when used in accordance with the instructions provided with your device. The above warranty extends only to the original retail purchaser.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 24 FCC STATEMENT Note: POTENTIAL FOR RADIO/TELEVISION INTERFERENCE (for U.S.A. only) This product has been tested and found to comply with the limits for a Class B digital device, pursuant to part 15 of the FCC rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation.
NE-C30-IM-FINAL 10/20/06 2:27 PM Page 25 SPECIFICATIONS Model: NE-C30 Type: Compressor nebulizer Power Supply: 12VDC 1A (Compressor) 100V-240VAC 50-60Hz (AC adapter) Power Consumption: 12 watts Nebulizer Rate: 0.35 ml/min (without cap) Particle Size: *MMD approximately 5 µm (based on EN13544-1) Medication Cup Capacity: 7 ml (cc) max.
